No photo of this model in the library yet.

Have this bike? Send a photo or the manual's service chart

Honda · Overhead-cam four-stroke single, wet sump, gearbox shares engine oil, chain drive

CB Twister (109 cc)

Library entry covers 2011-2014

30 factory 51 guideline

Published source

HONDA CB TWISTER owner's manual ((c) Honda Motor Co. 2010), maintenance schedule printed p.41-43 (ManualsLib 541444 p.49-51)

81 items for a 2014 model, grouped by interval the way a factory chart is laid out.

How this bike is built (what the schedule is based on)

Engine cycle: Four-stroke
Engine lubrication: Wet sump (oil in crankcase)
Oil filtration: Replaceable cartridge or spin-on filter
Valve gear: Overhead cam, screw/locknut adjusters
Ignition: Electronic (CDI / transistor / ECU)
Charging: Alternator / stator with rectifier
Battery: Wet cell (flooded lead-acid, needs topping up)
Fuel system: Single carburetor
Cooling: Air / oil cooled
Primary drive: Gear or chain inside engine, shares engine oil
Gearbox oil: Shares engine oil
Clutch control: Hand lever, cable
Final drive: Chain
Front suspension: Telescopic fork
Rear suspension: Swingarm, twin shocks
Front brake: Disc, hydraulic
Rear brake: Drum (or band / belt rim)
Wheels: Spoked, tubed
Sidecar: No sidecar

Maintenance schedule

2014 Honda CB Twister (109 cc)

On the road: every 300 km

1 item

Check engine oil level

Pre-ride / on the road

Guideline

Each fuel stop on old machines. Dry sump: check the tank hot, engine idling or just stopped, per your manual.

On the road: every 500 km

3 items

Check lights, horn, brake light switches

Pre-ride / on the road

Guideline
Check tire pressures

Pre-ride / on the road

Guideline
Lubricate drive chain

Pre-ride / on the road

Guideline

Lube warm, ideally at the end of the riding day so it soaks in overnight. Sooner after rain.

On the road: every 1,000 km

1 item

Check chain slack and rear wheel alignment

Pre-ride / on the road

Guideline

Every 1,000 km

1 item

Drive chain (inspect and lubricate)

Final drive

Factory

Factory: Maintenance schedule (HONDA CB TWISTER owner's manual, (c) 2010, printed p.41-43). Free services: 1st at 30 days/750 km, 2nd 90 days/3000 km, 3rd 150 days/6000 km, 4th 210 days/9000 km; then paid services every 60 days or 3000 km from the last service. The motorcycle must be serviced at every 3000 km or within 2 months, whichever comes first. Key: I inspect, clean, adjust, lubricate or replace if necessary; C clean; R replace; A adjust; L lubricate. Inspect and lubricate every 1000 km.

Every 1,600 km or 6 months

2 items

Adjust rear drum brake and rod / cable linkage

Brakes

Guideline
Inspect tire tread, sidewalls and date codes

Wheels and tires

Guideline

Every 3,000 km or 2 months

17 items

All other electrical switches (inspect)

Engine

Factory

Factory: Maintenance schedule (HONDA CB TWISTER owner's manual, (c) 2010, printed p.41-43). Free services: 1st at 30 days/750 km, 2nd 90 days/3000 km, 3rd 150 days/6000 km, 4th 210 days/9000 km; then paid services every 60 days or 3000 km from the last service. The motorcycle must be serviced at every 3000 km or within 2 months, whichever comes first. Key: I inspect, clean, adjust, lubricate or replace if necessary; C clean; R replace; A adjust; L lubricate. I at every service (every 3000 km or 2 months).
Choke operation (inspect)

Engine

Factory

Factory: Maintenance schedule (HONDA CB TWISTER owner's manual, (c) 2010, printed p.41-43). Free services: 1st at 30 days/750 km, 2nd 90 days/3000 km, 3rd 150 days/6000 km, 4th 210 days/9000 km; then paid services every 60 days or 3000 km from the last service. The motorcycle must be serviced at every 3000 km or within 2 months, whichever comes first. Key: I inspect, clean, adjust, lubricate or replace if necessary; C clean; R replace; A adjust; L lubricate. I at every service (every 3000 km or 2 months).
Crankcase breather (inspect and clean)

Engine

Factory

Factory: Maintenance schedule (HONDA CB TWISTER owner's manual, (c) 2010, printed p.41-43). Free services: 1st at 30 days/750 km, 2nd 90 days/3000 km, 3rd 150 days/6000 km, 4th 210 days/9000 km; then paid services every 60 days or 3000 km from the last service. The motorcycle must be serviced at every 3000 km or within 2 months, whichever comes first. Key: I inspect, clean, adjust, lubricate or replace if necessary; C clean; R replace; A adjust; L lubricate. I at every service (every 3000 km or 2 months).
Engine idle speed (inspect)

Engine

Factory

Factory: Maintenance schedule (HONDA CB TWISTER owner's manual, (c) 2010, printed p.41-43). Free services: 1st at 30 days/750 km, 2nd 90 days/3000 km, 3rd 150 days/6000 km, 4th 210 days/9000 km; then paid services every 60 days or 3000 km from the last service. The motorcycle must be serviced at every 3000 km or within 2 months, whichever comes first. Key: I inspect, clean, adjust, lubricate or replace if necessary; C clean; R replace; A adjust; L lubricate. I at every service (every 3000 km or 2 months).
Headlight aim (inspect)

Engine

Factory

Factory: Maintenance schedule (HONDA CB TWISTER owner's manual, (c) 2010, printed p.41-43). Free services: 1st at 30 days/750 km, 2nd 90 days/3000 km, 3rd 150 days/6000 km, 4th 210 days/9000 km; then paid services every 60 days or 3000 km from the last service. The motorcycle must be serviced at every 3000 km or within 2 months, whichever comes first. Key: I inspect, clean, adjust, lubricate or replace if necessary; C clean; R replace; A adjust; L lubricate. I at every service (every 3000 km or 2 months).
Nuts, bolts and fasteners (inspect)

Engine

Factory

Factory: Maintenance schedule (HONDA CB TWISTER owner's manual, (c) 2010, printed p.41-43). Free services: 1st at 30 days/750 km, 2nd 90 days/3000 km, 3rd 150 days/6000 km, 4th 210 days/9000 km; then paid services every 60 days or 3000 km from the last service. The motorcycle must be serviced at every 3000 km or within 2 months, whichever comes first. Key: I inspect, clean, adjust, lubricate or replace if necessary; C clean; R replace; A adjust; L lubricate. I at every service (every 3000 km or 2 months).
Secondary air supply system (inspect)

Engine

Factory

Factory: Maintenance schedule (HONDA CB TWISTER owner's manual, (c) 2010, printed p.41-43). Free services: 1st at 30 days/750 km, 2nd 90 days/3000 km, 3rd 150 days/6000 km, 4th 210 days/9000 km; then paid services every 60 days or 3000 km from the last service. The motorcycle must be serviced at every 3000 km or within 2 months, whichever comes first. Key: I inspect, clean, adjust, lubricate or replace if necessary; C clean; R replace; A adjust; L lubricate. I at every service (every 3000 km or 2 months).
Spark plug (inspect)

Engine

Factory

Factory: Maintenance schedule (HONDA CB TWISTER owner's manual, (c) 2010, printed p.41-43). Free services: 1st at 30 days/750 km, 2nd 90 days/3000 km, 3rd 150 days/6000 km, 4th 210 days/9000 km; then paid services every 60 days or 3000 km from the last service. The motorcycle must be serviced at every 3000 km or within 2 months, whichever comes first. Key: I inspect, clean, adjust, lubricate or replace if necessary; C clean; R replace; A adjust; L lubricate. I at every service (every 3000 km or 2 months).
Test drive

Engine

Factory

Factory: Maintenance schedule (HONDA CB TWISTER owner's manual, (c) 2010, printed p.41-43). Free services: 1st at 30 days/750 km, 2nd 90 days/3000 km, 3rd 150 days/6000 km, 4th 210 days/9000 km; then paid services every 60 days or 3000 km from the last service. The motorcycle must be serviced at every 3000 km or within 2 months, whichever comes first. Key: I inspect, clean, adjust, lubricate or replace if necessary; C clean; R replace; A adjust; L lubricate. At every service (every 3000 km or 2 months).
Throttle operation (inspect)

Engine

Factory

Factory: Maintenance schedule (HONDA CB TWISTER owner's manual, (c) 2010, printed p.41-43). Free services: 1st at 30 days/750 km, 2nd 90 days/3000 km, 3rd 150 days/6000 km, 4th 210 days/9000 km; then paid services every 60 days or 3000 km from the last service. The motorcycle must be serviced at every 3000 km or within 2 months, whichever comes first. Key: I inspect, clean, adjust, lubricate or replace if necessary; C clean; R replace; A adjust; L lubricate. I at every service (every 3000 km or 2 months).
Washing and cleaning

Engine

Factory

Factory: Maintenance schedule (HONDA CB TWISTER owner's manual, (c) 2010, printed p.41-43). Free services: 1st at 30 days/750 km, 2nd 90 days/3000 km, 3rd 150 days/6000 km, 4th 210 days/9000 km; then paid services every 60 days or 3000 km from the last service. The motorcycle must be serviced at every 3000 km or within 2 months, whichever comes first. Key: I inspect, clean, adjust, lubricate or replace if necessary; C clean; R replace; A adjust; L lubricate. C at every service (every 3000 km or 2 months).
Battery (check voltage)

Ignition and electrics

Factory

Factory: Maintenance schedule (HONDA CB TWISTER owner's manual, (c) 2010, printed p.41-43). Free services: 1st at 30 days/750 km, 2nd 90 days/3000 km, 3rd 150 days/6000 km, 4th 210 days/9000 km; then paid services every 60 days or 3000 km from the last service. The motorcycle must be serviced at every 3000 km or within 2 months, whichever comes first. Key: I inspect, clean, adjust, lubricate or replace if necessary; C clean; R replace; A adjust; L lubricate. I at every service (every 3000 km or 2 months).
Clutch system (inspect)

Primary and gearbox

Factory

Factory: Maintenance schedule (HONDA CB TWISTER owner's manual, (c) 2010, printed p.41-43). Free services: 1st at 30 days/750 km, 2nd 90 days/3000 km, 3rd 150 days/6000 km, 4th 210 days/9000 km; then paid services every 60 days or 3000 km from the last service. The motorcycle must be serviced at every 3000 km or within 2 months, whichever comes first. Key: I inspect, clean, adjust, lubricate or replace if necessary; C clean; R replace; A adjust; L lubricate. I at every service (every 3000 km or 2 months).
Steering movement (inspect)

Front end

Factory

Factory: Maintenance schedule (HONDA CB TWISTER owner's manual, (c) 2010, printed p.41-43). Free services: 1st at 30 days/750 km, 2nd 90 days/3000 km, 3rd 150 days/6000 km, 4th 210 days/9000 km; then paid services every 60 days or 3000 km from the last service. The motorcycle must be serviced at every 3000 km or within 2 months, whichever comes first. Key: I inspect, clean, adjust, lubricate or replace if necessary; C clean; R replace; A adjust; L lubricate. I at every service (every 3000 km or 2 months).
Brake fluid (inspect)

Brakes

Factory

Factory: Maintenance schedule (HONDA CB TWISTER owner's manual, (c) 2010, printed p.41-43). Free services: 1st at 30 days/750 km, 2nd 90 days/3000 km, 3rd 150 days/6000 km, 4th 210 days/9000 km; then paid services every 60 days or 3000 km from the last service. The motorcycle must be serviced at every 3000 km or within 2 months, whichever comes first. Key: I inspect, clean, adjust, lubricate or replace if necessary; C clean; R replace; A adjust; L lubricate. I at every service (every 3000 km or 2 months).
Brake light switch (inspect)

Brakes

Factory

Factory: Maintenance schedule (HONDA CB TWISTER owner's manual, (c) 2010, printed p.41-43). Free services: 1st at 30 days/750 km, 2nd 90 days/3000 km, 3rd 150 days/6000 km, 4th 210 days/9000 km; then paid services every 60 days or 3000 km from the last service. The motorcycle must be serviced at every 3000 km or within 2 months, whichever comes first. Key: I inspect, clean, adjust, lubricate or replace if necessary; C clean; R replace; A adjust; L lubricate. I at every service (every 3000 km or 2 months).
Wheels and tires (inspect)

Wheels and tires

Factory

Factory: Maintenance schedule (HONDA CB TWISTER owner's manual, (c) 2010, printed p.41-43). Free services: 1st at 30 days/750 km, 2nd 90 days/3000 km, 3rd 150 days/6000 km, 4th 210 days/9000 km; then paid services every 60 days or 3000 km from the last service. The motorcycle must be serviced at every 3000 km or within 2 months, whichever comes first. Key: I inspect, clean, adjust, lubricate or replace if necessary; C clean; R replace; A adjust; L lubricate. I at every service (every 3000 km or 2 months).

Every 5,000 km or 12 months

11 items

Check throttle cable(s) free play and return

Fuel and air

Guideline
Clean fuel tap filter / sediment bowl

Fuel and air

Guideline
Clean drive chain thoroughly (remove and soak, re-lube)

Final drive

Guideline

Non O-ring chains on old machines: remove, clean, soak in hot chain grease or lube, refit with the master link clip closed end leading.
Inspect chain and sprockets for wear (measure stretch)

Final drive

Guideline
Check steering head bearing adjustment

Front end

Guideline
Inspect fork seals, stanchions and fork boots

Front end

Guideline
Check footrests, pegs, rear brake and gear lever pivots

Rear suspension and frame

Guideline
Grease and check center / side stand and springs

Rear suspension and frame

Guideline
Check brake pads and discs

Brakes

Guideline
Check spoke tension and wheel true

Wheels and tires

Guideline
Check wheel bearings for play

Wheels and tires

Guideline

Every 6,000 km or 4 months

8 items

Engine oil (replace)

Engine

Factory

Factory: Maintenance schedule (HONDA CB TWISTER owner's manual, (c) 2010, printed p.41-43). Free services: 1st at 30 days/750 km, 2nd 90 days/3000 km, 3rd 150 days/6000 km, 4th 210 days/9000 km; then paid services every 60 days or 3000 km from the last service. The motorcycle must be serviced at every 3000 km or within 2 months, whichever comes first. Key: I inspect, clean, adjust, lubricate or replace if necessary; C clean; R replace; A adjust; L lubricate. R at 750 km, then every 6000 km; check at the services in between.
Engine oil strainer screen (clean)

Engine

Factory

Factory: Maintenance schedule (HONDA CB TWISTER owner's manual, (c) 2010, printed p.41-43). Free services: 1st at 30 days/750 km, 2nd 90 days/3000 km, 3rd 150 days/6000 km, 4th 210 days/9000 km; then paid services every 60 days or 3000 km from the last service. The motorcycle must be serviced at every 3000 km or within 2 months, whichever comes first. Key: I inspect, clean, adjust, lubricate or replace if necessary; C clean; R replace; A adjust; L lubricate. C at 750 km, then every 6000 km.
Suspension (inspect)

Engine

Factory

Factory: Maintenance schedule (HONDA CB TWISTER owner's manual, (c) 2010, printed p.41-43). Free services: 1st at 30 days/750 km, 2nd 90 days/3000 km, 3rd 150 days/6000 km, 4th 210 days/9000 km; then paid services every 60 days or 3000 km from the last service. The motorcycle must be serviced at every 3000 km or within 2 months, whichever comes first. Key: I inspect, clean, adjust, lubricate or replace if necessary; C clean; R replace; A adjust; L lubricate. I every 6000 km.
Valve clearance (inspect)

Engine

Factory

Factory: Maintenance schedule (HONDA CB TWISTER owner's manual, (c) 2010, printed p.41-43). Free services: 1st at 30 days/750 km, 2nd 90 days/3000 km, 3rd 150 days/6000 km, 4th 210 days/9000 km; then paid services every 60 days or 3000 km from the last service. The motorcycle must be serviced at every 3000 km or within 2 months, whichever comes first. Key: I inspect, clean, adjust, lubricate or replace if necessary; C clean; R replace; A adjust; L lubricate. I every 6000 km (dealer).
Fuel line (inspect)

Fuel and air

Factory

Factory: Maintenance schedule (HONDA CB TWISTER owner's manual, (c) 2010, printed p.41-43). Free services: 1st at 30 days/750 km, 2nd 90 days/3000 km, 3rd 150 days/6000 km, 4th 210 days/9000 km; then paid services every 60 days or 3000 km from the last service. The motorcycle must be serviced at every 3000 km or within 2 months, whichever comes first. Key: I inspect, clean, adjust, lubricate or replace if necessary; C clean; R replace; A adjust; L lubricate. I every 6000 km.
Fuel strainer screen (clean)

Fuel and air

Factory

Factory: Maintenance schedule (HONDA CB TWISTER owner's manual, (c) 2010, printed p.41-43). Free services: 1st at 30 days/750 km, 2nd 90 days/3000 km, 3rd 150 days/6000 km, 4th 210 days/9000 km; then paid services every 60 days or 3000 km from the last service. The motorcycle must be serviced at every 3000 km or within 2 months, whichever comes first. Key: I inspect, clean, adjust, lubricate or replace if necessary; C clean; R replace; A adjust; L lubricate. C every 6000 km.
Side stand (inspect)

Rear suspension and frame

Factory

Factory: Maintenance schedule (HONDA CB TWISTER owner's manual, (c) 2010, printed p.41-43). Free services: 1st at 30 days/750 km, 2nd 90 days/3000 km, 3rd 150 days/6000 km, 4th 210 days/9000 km; then paid services every 60 days or 3000 km from the last service. The motorcycle must be serviced at every 3000 km or within 2 months, whichever comes first. Key: I inspect, clean, adjust, lubricate or replace if necessary; C clean; R replace; A adjust; L lubricate. I every 6000 km.
Brake shoes, pads and disc wear (inspect)

Brakes

Factory

Factory: Maintenance schedule (HONDA CB TWISTER owner's manual, (c) 2010, printed p.41-43). Free services: 1st at 30 days/750 km, 2nd 90 days/3000 km, 3rd 150 days/6000 km, 4th 210 days/9000 km; then paid services every 60 days or 3000 km from the last service. The motorcycle must be serviced at every 3000 km or within 2 months, whichever comes first. Key: I inspect, clean, adjust, lubricate or replace if necessary; C clean; R replace; A adjust; L lubricate. I every 6000 km.

Every 6,500 km or 12 months

3 items

Inspect, clean and gap spark plugs

Engine

Guideline
Adjust clutch free play, lubricate cable and lever pivot

Primary and gearbox

Guideline
Lubricate brake cam spindles, check linings and drums

Brakes

Guideline

Every 8,000 km or 12 months

2 items

Change engine oil

Engine

Guideline

Pre-1970 machines: many owners run non-detergent or classic-spec oil with no filter, so short intervals matter. Dry sump: drain the tank and the crankcase/sump, flush the tank and clean the feed and return screens.
Replace oil filter

Engine

Guideline

Every 9,000 km

1 item

Spark plug (replace)

Engine

Factory

Factory: Maintenance schedule (HONDA CB TWISTER owner's manual, (c) 2010, printed p.41-43). Free services: 1st at 30 days/750 km, 2nd 90 days/3000 km, 3rd 150 days/6000 km, 4th 210 days/9000 km; then paid services every 60 days or 3000 km from the last service. The motorcycle must be serviced at every 3000 km or within 2 months, whichever comes first. Key: I inspect, clean, adjust, lubricate or replace if necessary; C clean; R replace; A adjust; L lubricate. Replace every 9000 km.

Every 9,500 km or 12 months

7 items

Clean / inspect air filter

Fuel and air

Guideline

Mesh or oiled foam: clean and re-oil. Paper: blow out or replace. Some very early machines have no filter at all.
Clean carburetor float bowl(s), check float level and jets

Fuel and air

Guideline

Ethanol fuel varnishes old carbs quickly in storage.
Check charging voltage and regulator / cut-out

Ignition and electrics

Guideline
Check swingarm bushes for play

Rear suspension and frame

Guideline
Inspect rear shocks for leaks and damping

Rear suspension and frame

Guideline
Lubricate control cables and lever pivots

Controls and cables

Guideline
Lubricate speedometer / tachometer cables, check drive

Controls and cables

Guideline

A dry speedo cable whips the needle and eventually kills the instrument.

Every 12,000 km

1 item

Engine oil centrifugal filter (clean)

Engine

Factory

Factory: Maintenance schedule (HONDA CB TWISTER owner's manual, (c) 2010, printed p.41-43). Free services: 1st at 30 days/750 km, 2nd 90 days/3000 km, 3rd 150 days/6000 km, 4th 210 days/9000 km; then paid services every 60 days or 3000 km from the last service. The motorcycle must be serviced at every 3000 km or within 2 months, whichever comes first. Key: I inspect, clean, adjust, lubricate or replace if necessary; C clean; R replace; A adjust; L lubricate. C at 750 km, then every 12000 km (dealer).

Every 13,000 km or 2 years

1 item

Check and adjust valve clearances

Engine

Guideline

Every 15,000 km

1 item

Air cleaner (replace)

Fuel and air

Factory

Factory: Maintenance schedule (HONDA CB TWISTER owner's manual, (c) 2010, printed p.41-43). Free services: 1st at 30 days/750 km, 2nd 90 days/3000 km, 3rd 150 days/6000 km, 4th 210 days/9000 km; then paid services every 60 days or 3000 km from the last service. The motorcycle must be serviced at every 3000 km or within 2 months, whichever comes first. Key: I inspect, clean, adjust, lubricate or replace if necessary; C clean; R replace; A adjust; L lubricate. Replace every 15000 km; do not open the element before 15000 km unless there is a drivability problem.

Every 16,000 km or 2 years

1 item

Compression test (or leak-down)

Engine

Guideline

Every 19,500 km or 2 years

2 items

Replace air filter element

Fuel and air

Guideline
Grease swingarm pivot

Rear suspension and frame

Guideline

Every 24,000 km or 3 years

1 item

Change fork oil

Front end

Guideline

Some early telescopic forks are grease filled or use very small oil quantities. Check your manual.

Every 24,000 km

1 item

Replace brake linings / skim drums (wear based)

Brakes

Guideline

Every 25,500 km or 4 years

1 item

Replace spark plugs

Engine

Guideline

Every 29,000 km

1 item

Replace chain and sprockets (wear based)

Final drive

Guideline

Every 32,000 km or 4 years

2 items

Repack / replace steering head bearings

Front end

Guideline

Many old machines use loose balls in cups and cones. Taper roller conversions are common.
Repack / replace wheel bearings

Wheels and tires

Guideline

Cup-and-cone and taper roller hubs need periodic repacking and adjustment.

Every 40,000 km or 6 years

1 item

Replace swingarm bushes / bearings

Rear suspension and frame

Guideline

Every 48,500 km or 6 years

1 item

Rebuild forks: seals, bushes, springs

Front end

Guideline

Every 6 months

1 item

Clean battery terminals, check charge and strap

Ignition and electrics

Guideline

Every 2 years

4 items

Inspect wiring, bullet connectors and ground points

Ignition and electrics

Guideline
Inspect frame, welds and lugs for cracks

Rear suspension and frame

Guideline
Brake fluid (replace)

Brakes

Factory

Factory: Maintenance schedule (HONDA CB TWISTER owner's manual, (c) 2010, printed p.41-43). Free services: 1st at 30 days/750 km, 2nd 90 days/3000 km, 3rd 150 days/6000 km, 4th 210 days/9000 km; then paid services every 60 days or 3000 km from the last service. The motorcycle must be serviced at every 3000 km or within 2 months, whichever comes first. Key: I inspect, clean, adjust, lubricate or replace if necessary; C clean; R replace; A adjust; L lubricate. Replace every 2 years.
Replace brake fluid

Brakes

Guideline

Every 4 years

3 items

Replace fuel lines

Fuel and air

Guideline

Old rubber and modern ethanol fuel do not mix well.
Inspect brake hoses; replace old rubber

Brakes

Guideline
Rebuild calipers and master cylinders (seals)

Brakes

Guideline

Every 6 years

2 items

Replace inner tubes and rim tape with tires

Wheels and tires

Guideline
Replace tires on age (regardless of tread)

Wheels and tires

Guideline

Guideline lines: Intervals here are general guidelines for the machine's era and layout, compiled for this app. They are not factory manual figures. Check your workshop manual, and edit any interval in the bike's Schedule tab.