CB400T / CM400 / CB450T Hawk
Library entry covers 1978-1985
Published source
Honda CB450/CM450/CB450SC Shop Manual, CB450T schedule (issue Nov 1981)
Factory workshop manual. Covers 1982-1985 (CB450T, from CB/CM450 shop manual).
74 items for a 1978 model, grouped by interval the way a factory chart is laid out.
How this bike is built (what the schedule is based on)
- Engine cycle
- Four-stroke
- Engine lubrication
- Wet sump (oil in crankcase)
- Oil filtration
- Centrifugal (slinger / rotor) filter
- Valve gear
- Overhead cam, screw/locknut adjusters
- Ignition
- Electronic (CDI / transistor / ECU)
- Charging
- Alternator / stator with rectifier
- Battery
- Wet cell (flooded lead-acid, needs topping up)
- Fuel system
- Two or more carburetors
- Cooling
- Air / oil cooled
- Primary drive
- Gear or chain inside engine, shares engine oil
- Gearbox oil
- Shares engine oil
- Clutch control
- Hand lever, cable
- Final drive
- Chain
- Front suspension
- Telescopic fork
- Rear suspension
- Swingarm, twin shocks
- Front brake
- Disc, hydraulic
- Rear brake
- Drum (or band / belt rim)
- Wheels
- Cast / alloy, tubeless
- Sidecar
- No sidecar
1978 Honda CB400T / CM400 / CB450T Hawk
On the road: every 200 mi
1 item-
Check engine oil levelPre-ride / on the roadGuideline
Each fuel stop on old machines. Dry sump: check the tank hot, engine idling or just stopped, per your manual.
On the road: every 300 mi
3 items-
Check lights, horn, brake light switchesPre-ride / on the roadGuideline
-
Check tire pressuresPre-ride / on the roadGuideline
-
Lubricate drive chainPre-ride / on the roadFactory
Manual: Drive chain inspect and lubricate. Factory: Schedule p.3-6 (CB450T): I, L every 300 mi (500 km)
On the road: every 600 mi
1 item-
Check chain slack and rear wheel alignmentPre-ride / on the roadGuideline
On the road: every 1,000 mi
1 item-
Check road kit: plugs, points file, master link, tube patches, wire, tapePre-ride / on the roadGuideline
On the road: every 4,000 mi
1 item-
Walk-around: check nuts and bolts for vibration looseningPre-ride / on the roadFactory
Manual: Nuts, bolts, fasteners. Factory: Schedule p.3-6 (CB450T): initial 600 mi, then every 4,000 mi
Every 1,000 mi or 6 months
2 items-
Adjust rear drum brake and rod / cable linkageBrakesGuideline
-
Inspect tire tread, sidewalls and date codesWheels and tiresGuideline
Every 1,500 mi or 6 months
1 item-
Clean drive chain thoroughly (remove and soak, re-lube)Final driveGuideline
Non O-ring chains on old machines: remove, clean, soak in hot chain grease or lube, refit with the master link clip closed end leading.
Every 2,000 mi or 12 months
4 items-
Change engine oilEngineFactory
Manual: Engine oil replace. Factory: Schedule p.3-6 (CB450T): initial 600 mi, then every year or 2,000 mi (3,200 km)
-
Inspect, clean and gap spark plugsEngineGuideline
-
Grease swingarm pivotRear suspension and frameGuideline
-
Lubricate control cables and lever pivotsControls and cablesGuideline
Every 3,000 mi or 12 months
10 items-
Adjust cam chain tensionerEngineGuideline
-
Check engine mounting bolts and platesEngineGuideline
-
Clean oil strainers / mesh screensEngineGuideline
Often done with every oil change on old machines.
-
Adjust clutch pushrod / clutch adjusterPrimary and gearboxGuideline
-
Check chain guard, chain oiler (if fitted), rear chain caseFinal driveGuideline
-
Inspect chain and sprockets for wear (measure stretch)Final driveGuideline
-
Check steering damper (friction or hydraulic)Front endGuideline
-
Inspect fork seals, stanchions and fork bootsFront endGuideline
-
Check footrests, pegs, rear brake and gear lever pivotsRear suspension and frameGuideline
-
Check wheel bearings for playWheels and tiresGuideline
Every 4,000 mi or 1 month
2 items-
Check battery electrolyte, top up with distilled waterIgnition and electricsFactory
Manual: Battery. Factory: Schedule p.3-6 (CB450T): monthly, plus initial 600 mi and every 4,000 mi
-
BRAKE FLUID (FRONT): I (inspect)BrakesFactory
Factory: As printed: MONTH I; I at 600 mi (1,000 km), 4,000 mi (6,400 km), 8,000 mi (12,800 km), 16,000 mi (25,600 km), 20,000 mi (32,000 km) (*R at 12,000 mi; 2 YEARS *R)
Every 4,000 mi or 12 months
2 items-
Replace oil filterEngineFactory
Manual: Engine oil filter replace. Factory: Schedule p.3-6 (CB450T): initial 600 mi, then every year or 4,000 mi
-
Lubricate brake cam spindles, check linings and drumsBrakesGuideline
Every 4,000 mi
19 items-
* HEADLIGHT AIMEngineFactory
Factory: As printed: I at 600 mi (1,000 km), 4,000 mi (6,400 km), 8,000 mi (12,800 km), 12,000 mi (19,200 km), 16,000 mi (25,600 km), 20,000 mi (32,000 km); refer to page 3-23
-
Check and adjust valve clearancesEngineFactory
Manual: Valve clearance. Factory: Schedule p.3-6 (CB450T): initial 600 mi, then every 4,000 mi
-
Check engine breather and oil returnEngineFactory
Manual: Crankcase breather clean. Factory: Schedule p.3-6 (CB450T): C every 4,000 mi; more often in rain/full throttle
-
Replace spark plugsEngineFactory
Manual: Spark plugs replace. Factory: Schedule p.3-6 (CB450T): R every 4,000 mi (6,400 km)
-
Carburetor chokeFuel and airFactory
Factory: Schedule p.3-6 (CB450T): every 4,000 mi (6,400 km)
-
Carburetor idle speedFuel and airFactory
Factory: Schedule p.3-6 (CB450T): initial 600 mi, then every 4,000 mi
-
Check throttle cable(s) free play and returnFuel and airFactory
Manual: Throttle operation. Factory: Schedule p.3-6 (CB450T): initial 600 mi, then every 4,000 mi
-
Clean / inspect air filterFuel and airFactory
Manual: Air cleaner clean. Factory: Schedule p.3-6 (CB450T): C every 4,000 mi; more often if dusty
-
Clean fuel tap filter / sediment bowlFuel and airFactory
Manual: Fuel strainer clean. Factory: Schedule p.3-6 (CB450T): C initial 600 mi, then every 4,000 mi (6,400 km)
-
Replace fuel linesFuel and airFactory
Manual: Fuel lines inspect. Factory: Schedule p.3-6 (CB450T): I at 4,000 mi then every 4,000 mi; inspect not replace
-
Synchronize carburetorsFuel and airFactory
Manual: Carburetor synchronization. Factory: Schedule p.3-6 (CB450T): initial 600 mi, then every 4,000 mi
-
Adjust clutch free play, lubricate cable and lever pivotPrimary and gearboxFactory
Manual: Clutch. Factory: Schedule p.3-6 (CB450T): initial 600 mi, then every 4,000 mi
-
Cam chain tension adjustFinal driveFactory
Factory: Schedule p.3-6 (CB450T): initial 600 mi, then every 4,000 mi
-
Grease and check center / side stand and springsRear suspension and frameFactory
Manual: Side stand. Factory: Schedule p.3-6 (CB450T): every 4,000 mi (6,400 km)
-
Inspect rear shocks for leaks and dampingRear suspension and frameFactory
Manual: Suspension. Factory: Schedule p.3-6 (CB450T): initial 600 mi, then every 4,000 mi
-
* BRAKE LIGHT SWITCHBrakesFactory
Factory: As printed: I at 600 mi (1,000 km), 4,000 mi (6,400 km), 8,000 mi (12,800 km), 12,000 mi (19,200 km), 16,000 mi (25,600 km), 20,000 mi (32,000 km); refer to page 3-23
-
Brake systemBrakesFactory
Factory: Schedule p.3-6 (CB450T): initial 600 mi, then every 4,000 mi
-
Check brake pads and discsBrakesFactory
Manual: Brake shoe/pad wear. Factory: Schedule p.3-6 (CB450T): every 4,000 mi (6,400 km)
-
Check spoke tension and wheel trueWheels and tiresFactory
Manual: Wheels. Factory: Schedule p.3-6 (CB450T): initial 600 mi, then every 4,000 mi
Every 5,000 mi or 2 years
1 item-
Check cylinder head bolt torqueEngineGuideline
Air-cooled iron and alloy engines can lose head bolt tension; follow your manual's sequence and whether it is done hot or cold.
Every 6,000 mi or 12 months
4 items-
Clean carburetor float bowl(s), check float level and jetsFuel and airGuideline
Ethanol fuel varnishes old carbs quickly in storage.
-
Check charging voltage and regulator / cut-outIgnition and electricsGuideline
-
Check swingarm bushes for playRear suspension and frameGuideline
-
Lubricate speedometer / tachometer cables, check driveControls and cablesGuideline
A dry speedo cable whips the needle and eventually kills the instrument.
Every 6,000 mi or 2 years
1 item-
Clean centrifugal oil filter (rotor / slinger)EngineGuideline
Every 8,000 mi
1 item-
Check steering head bearing adjustmentFront endFactory
Manual: Steering head bearing. Factory: Schedule p.3-6 (CB450T): initial 600 mi, then 8,000 and 16,000 mi
Every 10,000 mi or 2 years
2 items-
Compression test (or leak-down)EngineGuideline
-
Change fork oilFront endGuideline
Some early telescopic forks are grease filled or use very small oil quantities. Check your manual.
Every 10,000 mi
1 item-
Replace chain and sprockets (wear based)Final driveGuideline
Every 12,000 mi or 2 years
1 item-
Replace air filter elementFuel and airGuideline
Every 12,000 mi
1 item-
Balancer chain tension adjustFinal driveFactory
Factory: Schedule p.3-6 (CB450T): A at 12,000 mi only in chart
Every 15,000 mi or 5 years
1 item-
Inspect clutch plates and springsPrimary and gearboxGuideline
Every 15,000 mi
1 item-
Replace brake linings / skim drums (wear based)BrakesGuideline
Every 20,000 mi or 4 years
2 items-
Repack / replace steering head bearingsFront endGuideline
Many old machines use loose balls in cups and cones. Taper roller conversions are common.
-
Repack / replace wheel bearingsWheels and tiresGuideline
Cup-and-cone and taper roller hubs need periodic repacking and adjustment.
Every 25,000 mi or 6 years
1 item-
Replace swingarm bushes / bearingsRear suspension and frameGuideline
Every 30,000 mi or 6 years
1 item-
Rebuild forks: seals, bushes, springsFront endGuideline
Every 6 months
1 item-
Clean battery terminals, check charge and strapIgnition and electricsGuideline
Every 12 months
1 item-
Check speedometer / odometer against a known distanceControls and cablesGuideline
Old speedos drift with tire size and drive wear. Use phone GPS over a measured 10 miles / km.
Every 2 years
4 items-
Inspect fuel tank for rust, sealer failure, leaksFuel and airGuideline
-
Inspect wiring, bullet connectors and ground pointsIgnition and electricsGuideline
-
Inspect frame, welds and lugs for cracksRear suspension and frameGuideline
-
Replace brake fluidBrakesFactory
Manual: Brake fluid (front) replace. Factory: Schedule p.3-6 (CB450T): inspect monthly, replace every 2 years
Every 4 years
2 items-
Inspect brake hoses; replace old rubberBrakesGuideline
-
Rebuild calipers and master cylinders (seals)BrakesGuideline
Every 6 years
1 item-
Replace tires on age (regardless of tread)Wheels and tiresGuideline
Guideline lines: Intervals here are general guidelines for the machine's era and layout, compiled for this app. They are not factory manual figures. Check your workshop manual, and edit any interval in the bike's Schedule tab.
Keep up with this schedule on your phone
Add the bike in the app and this chart loads itself, ready to log against and edit.
Other 1978 Honda models
All 1978 Honda






