No photo of this model in the library yet.

Have this bike? Send a photo or the manual's service chart

Moto Guzzi · Pushrod four-stroke twin, wet sump, gearbox shares engine oil, shaft drive

1200 Sport

Library entry covers 2007-2015

38 factory 47 guideline

Published source

Moto Guzzi 1200 Sport 4V Use and Maintenance Manual (ES/EN), Routine maintenance table pp.145-147 (thisoldtractor.com)

Factory source. Covers Moto Guzzi 1200 Sport 4V use and maintenance manual (Spanish/English); the earlier 2-valve 1200 Sport is not covered.

85 items for a 2012 model, grouped by interval the way a factory chart is laid out.

How this bike is built (what the schedule is based on)

Engine cycle: Four-stroke
Engine lubrication: Wet sump (oil in crankcase)
Oil filtration: Replaceable cartridge or spin-on filter
Valve gear: Overhead valve, pushrods, adjustable tappets
Ignition: Electronic (CDI / transistor / ECU)
Charging: Alternator / stator with rectifier
Battery: Wet cell (flooded lead-acid, needs topping up)
Fuel system: Fuel injection
Cooling: Air / oil cooled
Primary drive: Gear or chain inside engine, shares engine oil
Gearbox oil: Shares engine oil
Clutch control: Hand lever, cable
Final drive: Shaft
Front suspension: Telescopic fork
Rear suspension: Swingarm, single shock / cantilever
Front brake: Disc, hydraulic
Rear brake: Disc, hydraulic
Wheels: Spoked, tubed
Sidecar: No sidecar

Maintenance schedule

2012 Moto Guzzi 1200 Sport

On the road: every 300 km

1 item

Check engine oil level

Pre-ride / on the road

Guideline

Each fuel stop on old machines. Dry sump: check the tank hot, engine idling or just stopped, per your manual.

On the road: every 500 km

2 items

Check lights, horn, brake light switches

Pre-ride / on the road

Guideline
Check tire pressures

Pre-ride / on the road

Guideline

Every 1,600 km or 6 months

1 item

Inspect tire tread, sidewalls and date codes

Wheels and tires

Guideline

Every 5,000 km or 12 months

8 items

Check throttle cable(s) free play and return

Fuel and air

Guideline
Check steering head bearing adjustment

Front end

Guideline
Inspect fork seals, stanchions and fork boots

Front end

Guideline
Check footrests, pegs, rear brake and gear lever pivots

Rear suspension and frame

Guideline
Grease and check center / side stand and springs

Rear suspension and frame

Guideline
Check brake pads and discs

Brakes

Guideline
Check spoke tension and wheel true

Wheels and tires

Guideline
Check wheel bearings for play

Wheels and tires

Guideline

Every 6,500 km or 12 months

2 items

Inspect, clean and gap spark plugs

Engine

Guideline
Adjust clutch free play, lubricate cable and lever pivot

Primary and gearbox

Guideline

Every 8,000 km or 12 months

2 items

Change engine oil

Engine

Guideline

Pre-1970 machines: many owners run non-detergent or classic-spec oil with no filter, so short intervals matter. Dry sump: drain the tank and the crankcase/sump, flush the tank and clean the feed and return screens.
Replace oil filter

Engine

Guideline

Every 9,500 km or 12 months

7 items

Clean / inspect air filter

Fuel and air

Guideline

Mesh or oiled foam: clean and re-oil. Paper: blow out or replace. Some very early machines have no filter at all.
Check charging voltage and regulator / cut-out

Ignition and electrics

Guideline
Check final drive for leaks and bearing play

Final drive

Guideline
Check swingarm bushes for play

Rear suspension and frame

Guideline
Inspect rear shocks for leaks and damping

Rear suspension and frame

Guideline
Lubricate control cables and lever pivots

Controls and cables

Guideline
Lubricate speedometer / tachometer cables, check drive

Controls and cables

Guideline

A dry speedo cable whips the needle and eventually kills the instrument.

Every 10,000 km or 1 month

1 item

Tire pressure and wear (inspect; check monthly)

Wheels and tires

Factory

Factory: Routine maintenance table (Moto Guzzi 1200 Sport 4V use and maintenance manual, Spanish/English, chapter 6 programd maintenance, printed pp.145-147): at 1,500 km, then every 10,000 km. Columns as printed: 1,500 km, then every 10,000 km to 80,000 km. Key: I inspect and clean, adjust, lubricate or replace if necessary; C clean; R replace; A adjust; L lubricate. Halve the intervals in rainy or dusty conditions, off road or track use. * check before every ride; ** replace every 2 years or 20,000 km (12,427 mi); *** replace every 4 years; **** at every start-up; ***** check monthly. This manual covers the 4-valve 1200 Sport; the earlier 2-valve version may differ.

Every 10,000 km

23 items

Bolts and nuts tightening (inspect)

Engine

Factory

Factory: Routine maintenance table (Moto Guzzi 1200 Sport 4V use and maintenance manual, Spanish/English, chapter 6 programd maintenance, printed pp.145-147): at 1,500 km, then every 10,000 km. Columns as printed: 1,500 km, then every 10,000 km to 80,000 km. Key: I inspect and clean, adjust, lubricate or replace if necessary; C clean; R replace; A adjust; L lubricate. Halve the intervals in rainy or dusty conditions, off road or track use. * check before every ride; ** replace every 2 years or 20,000 km (12,427 mi); *** replace every 4 years; **** at every start-up; ***** check monthly. This manual covers the 4-valve 1200 Sport; the earlier 2-valve version may differ.
Cylinder synchronization (inspect)

Engine

Factory

Factory: Routine maintenance table (Moto Guzzi 1200 Sport 4V use and maintenance manual, Spanish/English, chapter 6 programd maintenance, printed pp.145-147): at 1,500 km, then every 10,000 km. Columns as printed: 1,500 km, then every 10,000 km to 80,000 km. Key: I inspect and clean, adjust, lubricate or replace if necessary; C clean; R replace; A adjust; L lubricate. Halve the intervals in rainy or dusty conditions, off road or track use. * check before every ride; ** replace every 2 years or 20,000 km (12,427 mi); *** replace every 4 years; **** at every start-up; ***** check monthly. This manual covers the 4-valve 1200 Sport; the earlier 2-valve version may differ.
Engine idle speed (adjust)

Engine

Factory

Factory: Routine maintenance table (Moto Guzzi 1200 Sport 4V use and maintenance manual, Spanish/English, chapter 6 programd maintenance, printed pp.145-147): at 1,500 km, then every 10,000 km. Columns as printed: 1,500 km, then every 10,000 km to 80,000 km. Key: I inspect and clean, adjust, lubricate or replace if necessary; C clean; R replace; A adjust; L lubricate. Halve the intervals in rainy or dusty conditions, off road or track use. * check before every ride; ** replace every 2 years or 20,000 km (12,427 mi); *** replace every 4 years; **** at every start-up; ***** check monthly. This manual covers the 4-valve 1200 Sport; the earlier 2-valve version may differ.
Engine oil (replace)

Engine

Factory

Factory: Routine maintenance table (Moto Guzzi 1200 Sport 4V use and maintenance manual, Spanish/English, chapter 6 programd maintenance, printed pp.145-147): at 1,500 km, then every 10,000 km. Columns as printed: 1,500 km, then every 10,000 km to 80,000 km. Key: I inspect and clean, adjust, lubricate or replace if necessary; C clean; R replace; A adjust; L lubricate. Halve the intervals in rainy or dusty conditions, off road or track use. * check before every ride; ** replace every 2 years or 20,000 km (12,427 mi); *** replace every 4 years; **** at every start-up; ***** check monthly. This manual covers the 4-valve 1200 Sport; the earlier 2-valve version may differ.
Engine oil filter (replace)

Engine

Factory

Factory: Routine maintenance table (Moto Guzzi 1200 Sport 4V use and maintenance manual, Spanish/English, chapter 6 programd maintenance, printed pp.145-147): at 1,500 km, then every 10,000 km. Columns as printed: 1,500 km, then every 10,000 km to 80,000 km. Key: I inspect and clean, adjust, lubricate or replace if necessary; C clean; R replace; A adjust; L lubricate. Halve the intervals in rainy or dusty conditions, off road or track use. * check before every ride; ** replace every 2 years or 20,000 km (12,427 mi); *** replace every 4 years; **** at every start-up; ***** check monthly. This manual covers the 4-valve 1200 Sport; the earlier 2-valve version may differ.
Final drive oil (replace)

Engine

Factory

Factory: Routine maintenance table (Moto Guzzi 1200 Sport 4V use and maintenance manual, Spanish/English, chapter 6 programd maintenance, printed pp.145-147): at 1,500 km, then every 10,000 km. Columns as printed: 1,500 km, then every 10,000 km to 80,000 km. Key: I inspect and clean, adjust, lubricate or replace if necessary; C clean; R replace; A adjust; L lubricate. Halve the intervals in rainy or dusty conditions, off road or track use. * check before every ride; ** replace every 2 years or 20,000 km (12,427 mi); *** replace every 4 years; **** at every start-up; ***** check monthly. This manual covers the 4-valve 1200 Sport; the earlier 2-valve version may differ.
Idle mixture (CO) (inspect)

Engine

Factory

Factory: Routine maintenance table (Moto Guzzi 1200 Sport 4V use and maintenance manual, Spanish/English, chapter 6 programd maintenance, printed pp.145-147): every 10,000 km. Columns as printed: 1,500 km, then every 10,000 km to 80,000 km. Key: I inspect and clean, adjust, lubricate or replace if necessary; C clean; R replace; A adjust; L lubricate. Halve the intervals in rainy or dusty conditions, off road or track use. * check before every ride; ** replace every 2 years or 20,000 km (12,427 mi); *** replace every 4 years; **** at every start-up; ***** check monthly. This manual covers the 4-valve 1200 Sport; the earlier 2-valve version may differ.
Light aiming (inspect)

Engine

Factory

Factory: Routine maintenance table (Moto Guzzi 1200 Sport 4V use and maintenance manual, Spanish/English, chapter 6 programd maintenance, printed pp.145-147): every 10,000 km. Columns as printed: 1,500 km, then every 10,000 km to 80,000 km. Key: I inspect and clean, adjust, lubricate or replace if necessary; C clean; R replace; A adjust; L lubricate. Halve the intervals in rainy or dusty conditions, off road or track use. * check before every ride; ** replace every 2 years or 20,000 km (12,427 mi); *** replace every 4 years; **** at every start-up; ***** check monthly. This manual covers the 4-valve 1200 Sport; the earlier 2-valve version may differ.
Oil drain pipe from the filter housing (empty)

Engine

Factory

Factory: Routine maintenance table (Moto Guzzi 1200 Sport 4V use and maintenance manual, Spanish/English, chapter 6 programd maintenance, printed pp.145-147): every 10,000 km. Columns as printed: 1,500 km, then every 10,000 km to 80,000 km. Key: I inspect and clean, adjust, lubricate or replace if necessary; C clean; R replace; A adjust; L lubricate. Halve the intervals in rainy or dusty conditions, off road or track use. * check before every ride; ** replace every 2 years or 20,000 km (12,427 mi); *** replace every 4 years; **** at every start-up; ***** check monthly. This manual covers the 4-valve 1200 Sport; the earlier 2-valve version may differ.
Spark plugs (replace)

Engine

Factory

Factory: Routine maintenance table (Moto Guzzi 1200 Sport 4V use and maintenance manual, Spanish/English, chapter 6 programd maintenance, printed pp.145-147): every 10,000 km. Columns as printed: 1,500 km, then every 10,000 km to 80,000 km. Key: I inspect and clean, adjust, lubricate or replace if necessary; C clean; R replace; A adjust; L lubricate. Halve the intervals in rainy or dusty conditions, off road or track use. * check before every ride; ** replace every 2 years or 20,000 km (12,427 mi); *** replace every 4 years; **** at every start-up; ***** check monthly. This manual covers the 4-valve 1200 Sport; the earlier 2-valve version may differ.
Valve clearance (adjust)

Engine

Factory

Factory: Routine maintenance table (Moto Guzzi 1200 Sport 4V use and maintenance manual, Spanish/English, chapter 6 programd maintenance, printed pp.145-147): at 1,500 km, then every 10,000 km. Columns as printed: 1,500 km, then every 10,000 km to 80,000 km. Key: I inspect and clean, adjust, lubricate or replace if necessary; C clean; R replace; A adjust; L lubricate. Halve the intervals in rainy or dusty conditions, off road or track use. * check before every ride; ** replace every 2 years or 20,000 km (12,427 mi); *** replace every 4 years; **** at every start-up; ***** check monthly. This manual covers the 4-valve 1200 Sport; the earlier 2-valve version may differ.
Vehicle general operation, braking systems, light circuit (inspect)

Engine

Factory

Factory: Routine maintenance table (Moto Guzzi 1200 Sport 4V use and maintenance manual, Spanish/English, chapter 6 programd maintenance, printed pp.145-147): at 1,500 km, then every 10,000 km. Columns as printed: 1,500 km, then every 10,000 km to 80,000 km. Key: I inspect and clean, adjust, lubricate or replace if necessary; C clean; R replace; A adjust; L lubricate. Halve the intervals in rainy or dusty conditions, off road or track use. * check before every ride; ** replace every 2 years or 20,000 km (12,427 mi); *** replace every 4 years; **** at every start-up; ***** check monthly. This manual covers the 4-valve 1200 Sport; the earlier 2-valve version may differ.
Fuel pipes (inspect)

Fuel and air

Factory

Factory: Routine maintenance table (Moto Guzzi 1200 Sport 4V use and maintenance manual, Spanish/English, chapter 6 programd maintenance, printed pp.145-147): every 10,000 km. Columns as printed: 1,500 km, then every 10,000 km to 80,000 km. Key: I inspect and clean, adjust, lubricate or replace if necessary; C clean; R replace; A adjust; L lubricate. Halve the intervals in rainy or dusty conditions, off road or track use. * check before every ride; ** replace every 2 years or 20,000 km (12,427 mi); *** replace every 4 years; **** at every start-up; ***** check monthly. This manual covers the 4-valve 1200 Sport; the earlier 2-valve version may differ.
Clutch wear (inspect)

Primary and gearbox

Factory

Factory: Routine maintenance table (Moto Guzzi 1200 Sport 4V use and maintenance manual, Spanish/English, chapter 6 programd maintenance, printed pp.145-147): every 10,000 km. Columns as printed: 1,500 km, then every 10,000 km to 80,000 km. Key: I inspect and clean, adjust, lubricate or replace if necessary; C clean; R replace; A adjust; L lubricate. Halve the intervals in rainy or dusty conditions, off road or track use. * check before every ride; ** replace every 2 years or 20,000 km (12,427 mi); *** replace every 4 years; **** at every start-up; ***** check monthly. This manual covers the 4-valve 1200 Sport; the earlier 2-valve version may differ.
Gearbox oil (replace)

Primary and gearbox

Factory

Factory: Routine maintenance table (Moto Guzzi 1200 Sport 4V use and maintenance manual, Spanish/English, chapter 6 programd maintenance, printed pp.145-147): at 1,500 km, then every 10,000 km. Columns as printed: 1,500 km, then every 10,000 km to 80,000 km. Key: I inspect and clean, adjust, lubricate or replace if necessary; C clean; R replace; A adjust; L lubricate. Halve the intervals in rainy or dusty conditions, off road or track use. * check before every ride; ** replace every 2 years or 20,000 km (12,427 mi); *** replace every 4 years; **** at every start-up; ***** check monthly. This manual covers the 4-valve 1200 Sport; the earlier 2-valve version may differ.
Transmission cables and controls (inspect)

Primary and gearbox

Factory

Factory: Routine maintenance table (Moto Guzzi 1200 Sport 4V use and maintenance manual, Spanish/English, chapter 6 programd maintenance, printed pp.145-147): at 1,500 km, then every 10,000 km. Columns as printed: 1,500 km, then every 10,000 km to 80,000 km. Key: I inspect and clean, adjust, lubricate or replace if necessary; C clean; R replace; A adjust; L lubricate. Halve the intervals in rainy or dusty conditions, off road or track use. * check before every ride; ** replace every 2 years or 20,000 km (12,427 mi); *** replace every 4 years; **** at every start-up; ***** check monthly. This manual covers the 4-valve 1200 Sport; the earlier 2-valve version may differ.
Steering bearings and steering clearance (inspect)

Front end

Factory

Factory: Routine maintenance table (Moto Guzzi 1200 Sport 4V use and maintenance manual, Spanish/English, chapter 6 programd maintenance, printed pp.145-147): at 1,500 km, then every 10,000 km. Columns as printed: 1,500 km, then every 10,000 km to 80,000 km. Key: I inspect and clean, adjust, lubricate or replace if necessary; C clean; R replace; A adjust; L lubricate. Halve the intervals in rainy or dusty conditions, off road or track use. * check before every ride; ** replace every 2 years or 20,000 km (12,427 mi); *** replace every 4 years; **** at every start-up; ***** check monthly. This manual covers the 4-valve 1200 Sport; the earlier 2-valve version may differ.
Brake discs (inspect)

Brakes

Factory

Factory: Routine maintenance table (Moto Guzzi 1200 Sport 4V use and maintenance manual, Spanish/English, chapter 6 programd maintenance, printed pp.145-147): at 1,500 km, then every 10,000 km. Columns as printed: 1,500 km, then every 10,000 km to 80,000 km. Key: I inspect and clean, adjust, lubricate or replace if necessary; C clean; R replace; A adjust; L lubricate. Halve the intervals in rainy or dusty conditions, off road or track use. * check before every ride; ** replace every 2 years or 20,000 km (12,427 mi); *** replace every 4 years; **** at every start-up; ***** check monthly. This manual covers the 4-valve 1200 Sport; the earlier 2-valve version may differ.
Brake fluid and clutch fluid (inspect)

Brakes

Factory

Factory: Routine maintenance table (Moto Guzzi 1200 Sport 4V use and maintenance manual, Spanish/English, chapter 6 programd maintenance, printed pp.145-147): at 1,500 km, then every 10,000 km. Columns as printed: 1,500 km, then every 10,000 km to 80,000 km. Key: I inspect and clean, adjust, lubricate or replace if necessary; C clean; R replace; A adjust; L lubricate. Halve the intervals in rainy or dusty conditions, off road or track use. * check before every ride; ** replace every 2 years or 20,000 km (12,427 mi); *** replace every 4 years; **** at every start-up; ***** check monthly. This manual covers the 4-valve 1200 Sport; the earlier 2-valve version may differ.
Brake pad wear (inspect; before every ride)

Brakes

Factory

Factory: Routine maintenance table (Moto Guzzi 1200 Sport 4V use and maintenance manual, Spanish/English, chapter 6 programd maintenance, printed pp.145-147): at 1,500 km, then every 10,000 km. Columns as printed: 1,500 km, then every 10,000 km to 80,000 km. Key: I inspect and clean, adjust, lubricate or replace if necessary; C clean; R replace; A adjust; L lubricate. Halve the intervals in rainy or dusty conditions, off road or track use. * check before every ride; ** replace every 2 years or 20,000 km (12,427 mi); *** replace every 4 years; **** at every start-up; ***** check monthly. This manual covers the 4-valve 1200 Sport; the earlier 2-valve version may differ.
Brake pipes (inspect)

Brakes

Factory

Factory: Routine maintenance table (Moto Guzzi 1200 Sport 4V use and maintenance manual, Spanish/English, chapter 6 programd maintenance, printed pp.145-147): every 10,000 km. Columns as printed: 1,500 km, then every 10,000 km to 80,000 km. Key: I inspect and clean, adjust, lubricate or replace if necessary; C clean; R replace; A adjust; L lubricate. Halve the intervals in rainy or dusty conditions, off road or track use. * check before every ride; ** replace every 2 years or 20,000 km (12,427 mi); *** replace every 4 years; **** at every start-up; ***** check monthly. This manual covers the 4-valve 1200 Sport; the earlier 2-valve version may differ.
Wheel bearings (inspect)

Wheels and tires

Factory

Factory: Routine maintenance table (Moto Guzzi 1200 Sport 4V use and maintenance manual, Spanish/English, chapter 6 programd maintenance, printed pp.145-147): every 10,000 km. Columns as printed: 1,500 km, then every 10,000 km to 80,000 km. Key: I inspect and clean, adjust, lubricate or replace if necessary; C clean; R replace; A adjust; L lubricate. Halve the intervals in rainy or dusty conditions, off road or track use. * check before every ride; ** replace every 2 years or 20,000 km (12,427 mi); *** replace every 4 years; **** at every start-up; ***** check monthly. This manual covers the 4-valve 1200 Sport; the earlier 2-valve version may differ.
Wheels (inspect)

Wheels and tires

Factory

Factory: Routine maintenance table (Moto Guzzi 1200 Sport 4V use and maintenance manual, Spanish/English, chapter 6 programd maintenance, printed pp.145-147): at 1,500 km, then every 10,000 km. Columns as printed: 1,500 km, then every 10,000 km to 80,000 km. Key: I inspect and clean, adjust, lubricate or replace if necessary; C clean; R replace; A adjust; L lubricate. Halve the intervals in rainy or dusty conditions, off road or track use. * check before every ride; ** replace every 2 years or 20,000 km (12,427 mi); *** replace every 4 years; **** at every start-up; ***** check monthly. This manual covers the 4-valve 1200 Sport; the earlier 2-valve version may differ.

Every 13,000 km or 2 years

1 item

Check and adjust valve clearances

Engine

Guideline

Every 16,000 km or 2 years

1 item

Compression test (or leak-down)

Engine

Guideline

Every 19,500 km or 2 years

5 items

Replace air filter element

Fuel and air

Guideline
Synchronize throttle bodies

Fuel and air

Guideline
Change final drive (rear drive) oil

Final drive

Guideline
Clean and grease rear suspension linkage

Rear suspension and frame

Guideline
Grease swingarm pivot

Rear suspension and frame

Guideline

Every 20,000 km or 2 years

1 item

Brake fluid and clutch fluid (replace)

Brakes

Factory

Factory: Routine maintenance table (Moto Guzzi 1200 Sport 4V use and maintenance manual, Spanish/English, chapter 6 programd maintenance, printed pp.145-147): every 2 years or 20,000 km. Columns as printed: 1,500 km, then every 10,000 km to 80,000 km. Key: I inspect and clean, adjust, lubricate or replace if necessary; C clean; R replace; A adjust; L lubricate. Halve the intervals in rainy or dusty conditions, off road or track use. * check before every ride; ** replace every 2 years or 20,000 km (12,427 mi); *** replace every 4 years; **** at every start-up; ***** check monthly. This manual covers the 4-valve 1200 Sport; the earlier 2-valve version may differ.

Every 20,000 km

8 items

Safety switches (inspect)

Engine

Factory

Factory: Routine maintenance table (Moto Guzzi 1200 Sport 4V use and maintenance manual, Spanish/English, chapter 6 programd maintenance, printed pp.145-147): at 1,500 km, then every 20,000 km. Columns as printed: 1,500 km, then every 10,000 km to 80,000 km. Key: I inspect and clean, adjust, lubricate or replace if necessary; C clean; R replace; A adjust; L lubricate. Halve the intervals in rainy or dusty conditions, off road or track use. * check before every ride; ** replace every 2 years or 20,000 km (12,427 mi); *** replace every 4 years; **** at every start-up; ***** check monthly. This manual covers the 4-valve 1200 Sport; the earlier 2-valve version may differ.
Suspensions and setting (inspect)

Engine

Factory

Factory: Routine maintenance table (Moto Guzzi 1200 Sport 4V use and maintenance manual, Spanish/English, chapter 6 programd maintenance, printed pp.145-147): at 1,500 km, then every 20,000 km. Columns as printed: 1,500 km, then every 10,000 km to 80,000 km. Key: I inspect and clean, adjust, lubricate or replace if necessary; C clean; R replace; A adjust; L lubricate. Halve the intervals in rainy or dusty conditions, off road or track use. * check before every ride; ** replace every 2 years or 20,000 km (12,427 mi); *** replace every 4 years; **** at every start-up; ***** check monthly. This manual covers the 4-valve 1200 Sport; the earlier 2-valve version may differ.
Throttle body (clean)

Engine

Factory

Factory: Routine maintenance table (Moto Guzzi 1200 Sport 4V use and maintenance manual, Spanish/English, chapter 6 programd maintenance, printed pp.145-147): every 20,000 km. Columns as printed: 1,500 km, then every 10,000 km to 80,000 km. Key: I inspect and clean, adjust, lubricate or replace if necessary; C clean; R replace; A adjust; L lubricate. Halve the intervals in rainy or dusty conditions, off road or track use. * check before every ride; ** replace every 2 years or 20,000 km (12,427 mi); *** replace every 4 years; **** at every start-up; ***** check monthly. This manual covers the 4-valve 1200 Sport; the earlier 2-valve version may differ.
Air filter (inspect)

Fuel and air

Factory

Factory: Routine maintenance table (Moto Guzzi 1200 Sport 4V use and maintenance manual, Spanish/English, chapter 6 programd maintenance, printed pp.145-147): at 10,000 km and every 20,000 km between replacements. Columns as printed: 1,500 km, then every 10,000 km to 80,000 km. Key: I inspect and clean, adjust, lubricate or replace if necessary; C clean; R replace; A adjust; L lubricate. Halve the intervals in rainy or dusty conditions, off road or track use. * check before every ride; ** replace every 2 years or 20,000 km (12,427 mi); *** replace every 4 years; **** at every start-up; ***** check monthly. This manual covers the 4-valve 1200 Sport; the earlier 2-valve version may differ.
Air filter (replace)

Fuel and air

Factory

Factory: Routine maintenance table (Moto Guzzi 1200 Sport 4V use and maintenance manual, Spanish/English, chapter 6 programd maintenance, printed pp.145-147): every 20,000 km. Columns as printed: 1,500 km, then every 10,000 km to 80,000 km. Key: I inspect and clean, adjust, lubricate or replace if necessary; C clean; R replace; A adjust; L lubricate. Halve the intervals in rainy or dusty conditions, off road or track use. * check before every ride; ** replace every 2 years or 20,000 km (12,427 mi); *** replace every 4 years; **** at every start-up; ***** check monthly. This manual covers the 4-valve 1200 Sport; the earlier 2-valve version may differ.
Battery terminals tightening (inspect)

Ignition and electrics

Factory

Factory: Routine maintenance table (Moto Guzzi 1200 Sport 4V use and maintenance manual, Spanish/English, chapter 6 programd maintenance, printed pp.145-147): at 1,500 km, then every 20,000 km. Columns as printed: 1,500 km, then every 10,000 km to 80,000 km. Key: I inspect and clean, adjust, lubricate or replace if necessary; C clean; R replace; A adjust; L lubricate. Halve the intervals in rainy or dusty conditions, off road or track use. * check before every ride; ** replace every 2 years or 20,000 km (12,427 mi); *** replace every 4 years; **** at every start-up; ***** check monthly. This manual covers the 4-valve 1200 Sport; the earlier 2-valve version may differ.
Generator (alternator) belt (adjust)

Ignition and electrics

Factory

Factory: Routine maintenance table (Moto Guzzi 1200 Sport 4V use and maintenance manual, Spanish/English, chapter 6 programd maintenance, printed pp.145-147): at 20,000, 40,000, 60,000 and 80,000 km; replace at 50,000 km. Columns as printed: 1,500 km, then every 10,000 km to 80,000 km. Key: I inspect and clean, adjust, lubricate or replace if necessary; C clean; R replace; A adjust; L lubricate. Halve the intervals in rainy or dusty conditions, off road or track use. * check before every ride; ** replace every 2 years or 20,000 km (12,427 mi); *** replace every 4 years; **** at every start-up; ***** check monthly. This manual covers the 4-valve 1200 Sport; the earlier 2-valve version may differ.
Fork (inspect)

Front end

Factory

Factory: Routine maintenance table (Moto Guzzi 1200 Sport 4V use and maintenance manual, Spanish/English, chapter 6 programd maintenance, printed pp.145-147): at 1,500 km, then every 20,000 km. Columns as printed: 1,500 km, then every 10,000 km to 80,000 km. Key: I inspect and clean, adjust, lubricate or replace if necessary; C clean; R replace; A adjust; L lubricate. Halve the intervals in rainy or dusty conditions, off road or track use. * check before every ride; ** replace every 2 years or 20,000 km (12,427 mi); *** replace every 4 years; **** at every start-up; ***** check monthly. This manual covers the 4-valve 1200 Sport; the earlier 2-valve version may differ.

Every 24,000 km or 3 years

1 item

Change fork oil

Front end

Guideline

Some early telescopic forks are grease filled or use very small oil quantities. Check your manual.

Every 25,500 km or 4 years

1 item

Replace spark plugs

Engine

Guideline

Every 30,000 km

1 item

Fork oil and oil seals (replace)

Front end

Factory

Factory: Routine maintenance table (Moto Guzzi 1200 Sport 4V use and maintenance manual, Spanish/English, chapter 6 programd maintenance, printed pp.145-147): at 10,000, 30,000 and 60,000 km as printed. Columns as printed: 1,500 km, then every 10,000 km to 80,000 km. Key: I inspect and clean, adjust, lubricate or replace if necessary; C clean; R replace; A adjust; L lubricate. Halve the intervals in rainy or dusty conditions, off road or track use. * check before every ride; ** replace every 2 years or 20,000 km (12,427 mi); *** replace every 4 years; **** at every start-up; ***** check monthly. This manual covers the 4-valve 1200 Sport; the earlier 2-valve version may differ.

Every 32,000 km or 4 years

3 items

Lubricate drive shaft splines / check U-joint

Final drive

Guideline
Repack / replace steering head bearings

Front end

Guideline

Many old machines use loose balls in cups and cones. Taper roller conversions are common.
Repack / replace wheel bearings

Wheels and tires

Guideline

Cup-and-cone and taper roller hubs need periodic repacking and adjustment.

Every 38,500 km or 4 years

1 item

Replace fuel filter

Fuel and air

Guideline

Every 40,000 km or 6 years

1 item

Replace swingarm bushes / bearings

Rear suspension and frame

Guideline

Every 48,500 km or 6 years

1 item

Rebuild forks: seals, bushes, springs

Front end

Guideline

Every 50,000 km

1 item

Generator (alternator) belt (replace)

Ignition and electrics

Factory

Factory: Routine maintenance table (Moto Guzzi 1200 Sport 4V use and maintenance manual, Spanish/English, chapter 6 programd maintenance, printed pp.145-147): at 50,000 km. Columns as printed: 1,500 km, then every 10,000 km to 80,000 km. Key: I inspect and clean, adjust, lubricate or replace if necessary; C clean; R replace; A adjust; L lubricate. Halve the intervals in rainy or dusty conditions, off road or track use. * check before every ride; ** replace every 2 years or 20,000 km (12,427 mi); *** replace every 4 years; **** at every start-up; ***** check monthly. This manual covers the 4-valve 1200 Sport; the earlier 2-valve version may differ.

Every 6 months

1 item

Clean battery terminals, check charge and strap

Ignition and electrics

Guideline

Every 2 years

3 items

Inspect wiring, bullet connectors and ground points

Ignition and electrics

Guideline
Inspect frame, welds and lugs for cracks

Rear suspension and frame

Guideline
Replace brake fluid

Brakes

Guideline

Every 4 years

5 items

Fuel pipes (replace)

Fuel and air

Factory

Factory: Routine maintenance table (Moto Guzzi 1200 Sport 4V use and maintenance manual, Spanish/English, chapter 6 programd maintenance, printed pp.145-147): every 4 years. Columns as printed: 1,500 km, then every 10,000 km to 80,000 km. Key: I inspect and clean, adjust, lubricate or replace if necessary; C clean; R replace; A adjust; L lubricate. Halve the intervals in rainy or dusty conditions, off road or track use. * check before every ride; ** replace every 2 years or 20,000 km (12,427 mi); *** replace every 4 years; **** at every start-up; ***** check monthly. This manual covers the 4-valve 1200 Sport; the earlier 2-valve version may differ.
Replace fuel lines

Fuel and air

Guideline

Old rubber and modern ethanol fuel do not mix well.
Brake pipes (replace)

Brakes

Factory

Factory: Routine maintenance table (Moto Guzzi 1200 Sport 4V use and maintenance manual, Spanish/English, chapter 6 programd maintenance, printed pp.145-147): every 4 years. Columns as printed: 1,500 km, then every 10,000 km to 80,000 km. Key: I inspect and clean, adjust, lubricate or replace if necessary; C clean; R replace; A adjust; L lubricate. Halve the intervals in rainy or dusty conditions, off road or track use. * check before every ride; ** replace every 2 years or 20,000 km (12,427 mi); *** replace every 4 years; **** at every start-up; ***** check monthly. This manual covers the 4-valve 1200 Sport; the earlier 2-valve version may differ.
Inspect brake hoses; replace old rubber

Brakes

Guideline
Rebuild calipers and master cylinders (seals)

Brakes

Guideline

Every 6 years

2 items

Replace inner tubes and rim tape with tires

Wheels and tires

Guideline
Replace tires on age (regardless of tread)

Wheels and tires

Guideline

No interval set

1 item

Engine oil pressure warning light (check)

Engine

Factory

Factory: Routine maintenance table (Moto Guzzi 1200 Sport 4V use and maintenance manual, Spanish/English, chapter 6 programd maintenance, printed pp.145-147): at every start-up. Columns as printed: 1,500 km, then every 10,000 km to 80,000 km. Key: I inspect and clean, adjust, lubricate or replace if necessary; C clean; R replace; A adjust; L lubricate. Halve the intervals in rainy or dusty conditions, off road or track use. * check before every ride; ** replace every 2 years or 20,000 km (12,427 mi); *** replace every 4 years; **** at every start-up; ***** check monthly. This manual covers the 4-valve 1200 Sport; the earlier 2-valve version may differ.

Guideline lines: Intervals here are general guidelines for the machine's era and layout, compiled for this app. They are not factory manual figures. Check your workshop manual, and edit any interval in the bike's Schedule tab.