No photo of this model in the library yet.

Suzuki · Shim-adjusted overhead-cam four-stroke, wet sump, gearbox shares engine oil, chain drive

GSX-R 150

Library entry covers 2020-2022

24 factory 29 guideline

Published source

Suzuki GSX-R150 Service Manual (2017), Periodic Maintenance Schedule Chart p. 0B-1

Factory workshop manual. Covers 2017- (GSX-R150 service manual; chart in km, miles and months).

Open the source

53 items for a 2021 model, grouped by interval the way a factory chart is laid out.

How this bike is built (what the schedule is based on)

Engine cycle: Four-stroke
Engine lubrication: Wet sump (oil in crankcase)
Oil filtration: Replaceable cartridge or spin-on filter
Valve gear: Overhead cam, shim adjusted (incl. desmo)
Ignition: Electronic (CDI / transistor / ECU)
Charging: Alternator / stator with rectifier
Battery: Wet cell (flooded lead-acid, needs topping up)
Fuel system: Fuel injection
Cooling: Liquid cooled
Primary drive: Gear or chain inside engine, shares engine oil
Gearbox oil: Shares engine oil
Clutch control: Hand lever, cable
Final drive: Chain
Front suspension: Telescopic fork
Rear suspension: Swingarm, single shock / cantilever
Front brake: Disc, hydraulic
Rear brake: Disc, hydraulic
Wheels: Cast / alloy, tubeless
Sidecar: No sidecar

Maintenance schedule

2021 Suzuki GSX-R 150

On the road: every 200 mi

1 item

Check engine oil level

Pre-ride / on the road

Guideline

Each fuel stop on old machines. Dry sump: check the tank hot, engine idling or just stopped, per your manual.

On the road: every 300 mi

2 items

Check lights, horn, brake light switches

Pre-ride / on the road

Guideline
Check tire pressures

Pre-ride / on the road

Guideline

On the road: every 500 mi

1 item

Check coolant level

Pre-ride / on the road

Guideline

On the road: every 600 mi

1 item

Lubricate drive chain

Pre-ride / on the road

Factory

Manual: Drive chain - clean and lubricate. Factory: Clean and lubricate every 1000 km (600 miles)

On the road: every 2,400 mi or 6 months

1 item

Check chain slack and rear wheel alignment

Pre-ride / on the road

Factory

Manual: Drive chain - I. Factory: Initial 1000 km; then every column

Every 600 mi

1 item

Lubricate control cables and lever pivots

Controls and cables

Factory

Manual: Lubrication - I. Factory: Lubricate every 1000 km (600 miles)

Every 2,400 mi or 6 months

9 items

Change engine oil

Engine

Factory

Manual: Engine oil - R. Factory: Initial 1000 km (600 mi)/1 month; columns 1000/4000/8000 km
Chassis bolts and nuts - T

Engine

Factory

Factory: Tighten initially 1000 km; then every column
Inspect coolant hoses and clamps

Engine

Factory

Manual: Radiator hose - I. Factory: Every column from 4000 km
Inspect, clean and gap spark plugs

Engine

Factory

Manual: Spark plug - I. Factory: Inspected at 4000 km column
Check throttle cable(s) free play and return

Fuel and air

Factory

Manual: Throttle cable play - I. Factory: Initial 1000 km; then every column
Clean / inspect air filter

Fuel and air

Factory

Manual: Air cleaner element - I. Factory: Inspected at 4000 and 8000 km columns
Adjust clutch free play, lubricate cable and lever pivot

Primary and gearbox

Factory

Manual: Clutch cable play - I. Factory: Every column from 4000 km
Check brake pads and discs

Brakes

Factory

Manual: Brake - I. Factory: Initial 1000 km; then every column
Inspect tire tread, sidewalls and date codes

Wheels and tires

Factory

Manual: Tires - I. Factory: Every column from 4000 km

Every 2,400 mi or 2 years

1 item

Replace brake fluid

Brakes

Factory

Manual: Brake fluid - I; replace every 2 years. Factory: Inspect every 4000 km; replace every 2 years

Every 2,400 mi or 4 years

2 items

Replace fuel lines

Fuel and air

Factory

Manual: Fuel hose - I; replace every 4 years. Factory: Inspect every 4000 km; replace every 4 years
Inspect brake hoses; replace old rubber

Brakes

Factory

Manual: Brake hose - I; replace every 4 years. Factory: Inspect every 4000 km; replace every 4 years

Every 3,000 mi or 12 months

5 items

Clean drive chain thoroughly (remove and soak, re-lube)

Final drive

Guideline

Non O-ring chains on old machines: remove, clean, soak in hot chain grease or lube, refit with the master link clip closed end leading.
Inspect chain and sprockets for wear (measure stretch)

Final drive

Guideline
Check footrests, pegs, rear brake and gear lever pivots

Rear suspension and frame

Guideline
Grease and check center / side stand and springs

Rear suspension and frame

Guideline
Check wheel bearings for play

Wheels and tires

Guideline

Every 4,800 mi or 12 months

7 items

Check and adjust valve clearances

Engine

Factory

Manual: Valve clearance - I. Factory: Only 8000 km (4800 mi) column marked
Exhaust pipe bolt and muffler bolt - T

Engine

Factory

Factory: Tighten initially 1000 km; then 8000 km column
Replace oil filter

Engine

Factory

Manual: Engine oil filter - R. Factory: Initial 1000 km; then 8000 km (4800 mi) column
Replace spark plugs

Engine

Factory

Manual: Spark plug - R. Factory: Replaced at 8000 km column
Check steering head bearing adjustment

Front end

Factory

Manual: Steering - I. Factory: Initial 1000 km; then 8000 km column
Inspect fork seals, stanchions and fork boots

Front end

Factory

Manual: Front forks - I. Factory: Only 8000 km column marked
Inspect rear shocks for leaks and damping

Rear suspension and frame

Factory

Manual: Rear suspension - I. Factory: Only 8000 km column marked

Every 6,000 mi or 12 months

3 items

Check charging voltage and regulator / cut-out

Ignition and electrics

Guideline
Check swingarm bushes for play

Rear suspension and frame

Guideline
Lubricate speedometer / tachometer cables, check drive

Controls and cables

Guideline

A dry speedo cable whips the needle and eventually kills the instrument.

Every 7,200 mi

1 item

Replace air filter element

Fuel and air

Factory

Manual: Air cleaner element - R. Factory: Replace every 12000 km (7200 miles)

Every 9,600 mi or 4 years

1 item

Replace coolant

Engine

Factory

Manual: Engine coolant (SUZUKI SUPER LONG LIFE COOLANT, blue) - R. Factory: Every 4 years or 16000 km (9600 miles); other coolant every 2 years or 8000 km

Every 10,000 mi or 2 years

1 item

Compression test (or leak-down)

Engine

Guideline

Every 12,000 mi or 2 years

3 items

Synchronize throttle bodies

Fuel and air

Guideline
Clean and grease rear suspension linkage

Rear suspension and frame

Guideline
Grease swingarm pivot

Rear suspension and frame

Guideline

Every 15,000 mi or 3 years

1 item

Change fork oil

Front end

Guideline

Some early telescopic forks are grease filled or use very small oil quantities. Check your manual.

Every 15,000 mi or 4 years

1 item

Check valve clearances (shim adjusted)

Engine

Guideline

Every 18,000 mi

1 item

Replace chain and sprockets (wear based)

Final drive

Guideline

Every 20,000 mi or 4 years

2 items

Repack / replace steering head bearings

Front end

Guideline

Many old machines use loose balls in cups and cones. Taper roller conversions are common.
Repack / replace wheel bearings

Wheels and tires

Guideline

Cup-and-cone and taper roller hubs need periodic repacking and adjustment.

Every 24,000 mi or 4 years

1 item

Replace fuel filter

Fuel and air

Guideline

Every 25,000 mi or 6 years

1 item

Replace swingarm bushes / bearings

Rear suspension and frame

Guideline

Every 30,000 mi or 6 years

1 item

Rebuild forks: seals, bushes, springs

Front end

Guideline

Every 6 months

1 item

Clean battery terminals, check charge and strap

Ignition and electrics

Guideline

Every 2 years

2 items

Inspect wiring, bullet connectors and ground points

Ignition and electrics

Guideline
Inspect frame, welds and lugs for cracks

Rear suspension and frame

Guideline

Every 4 years

1 item

Rebuild calipers and master cylinders (seals)

Brakes

Guideline

Every 6 years

1 item

Replace tires on age (regardless of tread)

Wheels and tires

Guideline

Guideline lines: Intervals here are general guidelines for the machine's era and layout, compiled for this app. They are not factory manual figures. Check your workshop manual, and edit any interval in the bike's Schedule tab.