No photo of this model in the library yet.

Have this bike? Send a photo or the manual's service chart

Suzuki · Overhead-cam four-stroke twin, wet sump, gearbox shares engine oil, shaft drive

VL 1500

Library entry covers 1998-2003

32 factory 46 guideline

Published source

Suzuki VL1500 service manual (VL1500W 1998, with VL1500X/Y supplements), periodic maintenance chart printed p.2-1 to 2-2 (ManualsLib 1000591 p.16)

Factory service manual. Covers Suzuki VL1500 service manual covering the 1998 VL1500W with 1999-2000 supplements; 2001-2003 not explicitly covered.

78 items for a 2002 model, grouped by interval the way a factory chart is laid out.

How this bike is built (what the schedule is based on)

Engine cycle: Four-stroke
Engine lubrication: Wet sump (oil in crankcase)
Oil filtration: Replaceable cartridge or spin-on filter
Valve gear: Overhead cam, screw/locknut adjusters
Ignition: Electronic (CDI / transistor / ECU)
Charging: Alternator / stator with rectifier
Battery: Wet cell (flooded lead-acid, needs topping up)
Fuel system: Two or more carburetors
Cooling: Air / oil cooled
Primary drive: Gear or chain inside engine, shares engine oil
Gearbox oil: Shares engine oil
Clutch control: Hand lever, cable
Final drive: Shaft
Front suspension: Telescopic fork
Rear suspension: Swingarm, single shock / cantilever
Front brake: Disc, hydraulic
Rear brake: Disc, hydraulic
Wheels: Cast / alloy, tubeless
Sidecar: No sidecar

Maintenance schedule

2002 Suzuki VL 1500

On the road: every 300 km

1 item

Check engine oil level

Pre-ride / on the road

Guideline

Each fuel stop on old machines. Dry sump: check the tank hot, engine idling or just stopped, per your manual.

On the road: every 500 km

2 items

Check lights, horn, brake light switches

Pre-ride / on the road

Guideline
Check tire pressures

Pre-ride / on the road

Guideline

Every 1,000 km or 1 month

1 item

Final gear oil (replace)

Engine

Factory

Factory: Periodic maintenance chart (Suzuki VL1500 service manual, printed p.2-1 to 2-2; interval columns 1,000 km (600 mi) or 1 month; 6,000 km (4,000 mi) or 6 months; 12,000 (7,500) or 12; 18,000 (11,000) or 18; 24,000 km (15,000 mi) or 24 months, whichever comes first). Codes: I inspect and clean, adjust, replace or lubricate as necessary; R replace; T tighten. More frequent servicing may be performed on motorcycles used under severe conditions. R at 1,000 km (600 mi) or 1 month.

Every 1,600 km or 6 months

1 item

Inspect tire tread, sidewalls and date codes

Wheels and tires

Guideline

Every 5,000 km or 12 months

8 items

Check throttle cable(s) free play and return

Fuel and air

Guideline
Clean fuel tap filter / sediment bowl

Fuel and air

Guideline
Check steering head bearing adjustment

Front end

Guideline
Inspect fork seals, stanchions and fork boots

Front end

Guideline
Check footrests, pegs, rear brake and gear lever pivots

Rear suspension and frame

Guideline
Grease and check center / side stand and springs

Rear suspension and frame

Guideline
Check brake pads and discs

Brakes

Guideline
Check wheel bearings for play

Wheels and tires

Guideline

Every 6,000 km or 6 months

13 items

Chassis bolts and nuts (tighten)

Engine

Factory

Factory: Periodic maintenance chart (Suzuki VL1500 service manual, printed p.2-1 to 2-2; interval columns 1,000 km (600 mi) or 1 month; 6,000 km (4,000 mi) or 6 months; 12,000 (7,500) or 12; 18,000 (11,000) or 18; 24,000 km (15,000 mi) or 24 months, whichever comes first). Codes: I inspect and clean, adjust, replace or lubricate as necessary; R replace; T tighten. More frequent servicing may be performed on motorcycles used under severe conditions. T at 1,000 km (600 mi) or 1 month, then every 6,000 km (4,000 mi) or 6 months.
Engine idle speed (inspect)

Engine

Factory

Factory: Periodic maintenance chart (Suzuki VL1500 service manual, printed p.2-1 to 2-2; interval columns 1,000 km (600 mi) or 1 month; 6,000 km (4,000 mi) or 6 months; 12,000 (7,500) or 12; 18,000 (11,000) or 18; 24,000 km (15,000 mi) or 24 months, whichever comes first). Codes: I inspect and clean, adjust, replace or lubricate as necessary; R replace; T tighten. More frequent servicing may be performed on motorcycles used under severe conditions. I at 1,000 km (600 mi) or 1 month, then every 6,000 km (4,000 mi) or 6 months.
Engine oil (replace)

Engine

Factory

Factory: Periodic maintenance chart (Suzuki VL1500 service manual, printed p.2-1 to 2-2; interval columns 1,000 km (600 mi) or 1 month; 6,000 km (4,000 mi) or 6 months; 12,000 (7,500) or 12; 18,000 (11,000) or 18; 24,000 km (15,000 mi) or 24 months, whichever comes first). Codes: I inspect and clean, adjust, replace or lubricate as necessary; R replace; T tighten. More frequent servicing may be performed on motorcycles used under severe conditions. R at 1,000 km (600 mi) or 1 month, then every 6,000 km (4,000 mi) or 6 months.
Spark plugs (inspect)

Engine

Factory

Factory: Periodic maintenance chart (Suzuki VL1500 service manual, printed p.2-1 to 2-2; interval columns 1,000 km (600 mi) or 1 month; 6,000 km (4,000 mi) or 6 months; 12,000 (7,500) or 12; 18,000 (11,000) or 18; 24,000 km (15,000 mi) or 24 months, whichever comes first). Codes: I inspect and clean, adjust, replace or lubricate as necessary; R replace; T tighten. More frequent servicing may be performed on motorcycles used under severe conditions. I at 6,000 and 18,000 km.
Air cleaner (inspect)

Fuel and air

Factory

Factory: Periodic maintenance chart (Suzuki VL1500 service manual, printed p.2-1 to 2-2; interval columns 1,000 km (600 mi) or 1 month; 6,000 km (4,000 mi) or 6 months; 12,000 (7,500) or 12; 18,000 (11,000) or 18; 24,000 km (15,000 mi) or 24 months, whichever comes first). Codes: I inspect and clean, adjust, replace or lubricate as necessary; R replace; T tighten. More frequent servicing may be performed on motorcycles used under severe conditions. I at 6,000, 12,000 and 24,000 km.
Clutch fluid (inspect)

Primary and gearbox

Factory

Factory: Periodic maintenance chart (Suzuki VL1500 service manual, printed p.2-1 to 2-2; interval columns 1,000 km (600 mi) or 1 month; 6,000 km (4,000 mi) or 6 months; 12,000 (7,500) or 12; 18,000 (11,000) or 18; 24,000 km (15,000 mi) or 24 months, whichever comes first). Codes: I inspect and clean, adjust, replace or lubricate as necessary; R replace; T tighten. More frequent servicing may be performed on motorcycles used under severe conditions. I every 6,000 km (4,000 mi) or 6 months.
Clutch hose (inspect)

Primary and gearbox

Factory

Factory: Periodic maintenance chart (Suzuki VL1500 service manual, printed p.2-1 to 2-2; interval columns 1,000 km (600 mi) or 1 month; 6,000 km (4,000 mi) or 6 months; 12,000 (7,500) or 12; 18,000 (11,000) or 18; 24,000 km (15,000 mi) or 24 months, whichever comes first). Codes: I inspect and clean, adjust, replace or lubricate as necessary; R replace; T tighten. More frequent servicing may be performed on motorcycles used under severe conditions. I every 6,000 km (4,000 mi) or 6 months.
Brake fluid (inspect)

Brakes

Factory

Factory: Periodic maintenance chart (Suzuki VL1500 service manual, printed p.2-1 to 2-2; interval columns 1,000 km (600 mi) or 1 month; 6,000 km (4,000 mi) or 6 months; 12,000 (7,500) or 12; 18,000 (11,000) or 18; 24,000 km (15,000 mi) or 24 months, whichever comes first). Codes: I inspect and clean, adjust, replace or lubricate as necessary; R replace; T tighten. More frequent servicing may be performed on motorcycles used under severe conditions. I every 6,000 km (4,000 mi) or 6 months.
Brake hose (inspect)

Brakes

Factory

Factory: Periodic maintenance chart (Suzuki VL1500 service manual, printed p.2-1 to 2-2; interval columns 1,000 km (600 mi) or 1 month; 6,000 km (4,000 mi) or 6 months; 12,000 (7,500) or 12; 18,000 (11,000) or 18; 24,000 km (15,000 mi) or 24 months, whichever comes first). Codes: I inspect and clean, adjust, replace or lubricate as necessary; R replace; T tighten. More frequent servicing may be performed on motorcycles used under severe conditions. I every 6,000 km (4,000 mi) or 6 months.
Brakes (inspect)

Brakes

Factory

Factory: Periodic maintenance chart (Suzuki VL1500 service manual, printed p.2-1 to 2-2; interval columns 1,000 km (600 mi) or 1 month; 6,000 km (4,000 mi) or 6 months; 12,000 (7,500) or 12; 18,000 (11,000) or 18; 24,000 km (15,000 mi) or 24 months, whichever comes first). Codes: I inspect and clean, adjust, replace or lubricate as necessary; R replace; T tighten. More frequent servicing may be performed on motorcycles used under severe conditions. I at 1,000 km (600 mi) or 1 month, then every 6,000 km (4,000 mi) or 6 months.
Tires (inspect)

Wheels and tires

Factory

Factory: Periodic maintenance chart (Suzuki VL1500 service manual, printed p.2-1 to 2-2; interval columns 1,000 km (600 mi) or 1 month; 6,000 km (4,000 mi) or 6 months; 12,000 (7,500) or 12; 18,000 (11,000) or 18; 24,000 km (15,000 mi) or 24 months, whichever comes first). Codes: I inspect and clean, adjust, replace or lubricate as necessary; R replace; T tighten. More frequent servicing may be performed on motorcycles used under severe conditions. I every 6,000 km (4,000 mi) or 6 months.
Automatic de-compression cable (inspect)

Controls and cables

Factory

Factory: Periodic maintenance chart (Suzuki VL1500 service manual, printed p.2-1 to 2-2; interval columns 1,000 km (600 mi) or 1 month; 6,000 km (4,000 mi) or 6 months; 12,000 (7,500) or 12; 18,000 (11,000) or 18; 24,000 km (15,000 mi) or 24 months, whichever comes first). Codes: I inspect and clean, adjust, replace or lubricate as necessary; R replace; T tighten. More frequent servicing may be performed on motorcycles used under severe conditions. I at 1,000 km (600 mi) or 1 month, then every 6,000 km (4,000 mi) or 6 months.
Throttle cable play (inspect)

Controls and cables

Factory

Factory: Periodic maintenance chart (Suzuki VL1500 service manual, printed p.2-1 to 2-2; interval columns 1,000 km (600 mi) or 1 month; 6,000 km (4,000 mi) or 6 months; 12,000 (7,500) or 12; 18,000 (11,000) or 18; 24,000 km (15,000 mi) or 24 months, whichever comes first). Codes: I inspect and clean, adjust, replace or lubricate as necessary; R replace; T tighten. More frequent servicing may be performed on motorcycles used under severe conditions. I at 1,000 km (600 mi) or 1 month, then every 6,000 km (4,000 mi) or 6 months.

Every 6,500 km or 12 months

2 items

Inspect, clean and gap spark plugs

Engine

Guideline
Adjust clutch free play, lubricate cable and lever pivot

Primary and gearbox

Guideline

Every 8,000 km or 12 months

2 items

Change engine oil

Engine

Guideline

Pre-1970 machines: many owners run non-detergent or classic-spec oil with no filter, so short intervals matter. Dry sump: drain the tank and the crankcase/sump, flush the tank and clean the feed and return screens.
Replace oil filter

Engine

Guideline

Every 9,500 km or 12 months

9 items

Clean / inspect air filter

Fuel and air

Guideline

Mesh or oiled foam: clean and re-oil. Paper: blow out or replace. Some very early machines have no filter at all.
Clean carburetor float bowl(s), check float level and jets

Fuel and air

Guideline

Ethanol fuel varnishes old carbs quickly in storage.
Synchronize carburetors

Fuel and air

Guideline
Check charging voltage and regulator / cut-out

Ignition and electrics

Guideline
Check final drive for leaks and bearing play

Final drive

Guideline
Check swingarm bushes for play

Rear suspension and frame

Guideline
Inspect rear shocks for leaks and damping

Rear suspension and frame

Guideline
Lubricate control cables and lever pivots

Controls and cables

Guideline
Lubricate speedometer / tachometer cables, check drive

Controls and cables

Guideline

A dry speedo cable whips the needle and eventually kills the instrument.

Every 12,000 km or 12 months

11 items

Exhaust pipe bolts and muffler bolts (tighten)

Engine

Factory

Factory: Periodic maintenance chart (Suzuki VL1500 service manual, printed p.2-1 to 2-2; interval columns 1,000 km (600 mi) or 1 month; 6,000 km (4,000 mi) or 6 months; 12,000 (7,500) or 12; 18,000 (11,000) or 18; 24,000 km (15,000 mi) or 24 months, whichever comes first). Codes: I inspect and clean, adjust, replace or lubricate as necessary; R replace; T tighten. More frequent servicing may be performed on motorcycles used under severe conditions. T at 1,000 km (600 mi) or 1 month, then every 12,000 km (7,500 mi) or 12 months.
Final gear oil (inspect)

Engine

Factory

Factory: Periodic maintenance chart (Suzuki VL1500 service manual, printed p.2-1 to 2-2; interval columns 1,000 km (600 mi) or 1 month; 6,000 km (4,000 mi) or 6 months; 12,000 (7,500) or 12; 18,000 (11,000) or 18; 24,000 km (15,000 mi) or 24 months, whichever comes first). Codes: I inspect and clean, adjust, replace or lubricate as necessary; R replace; T tighten. More frequent servicing may be performed on motorcycles used under severe conditions. I every 12,000 km (7,500 mi) or 12 months.
PAIR (air supply) system (inspect)

Engine

Factory

Factory: Periodic maintenance chart (Suzuki VL1500 service manual, printed p.2-1 to 2-2; interval columns 1,000 km (600 mi) or 1 month; 6,000 km (4,000 mi) or 6 months; 12,000 (7,500) or 12; 18,000 (11,000) or 18; 24,000 km (15,000 mi) or 24 months, whichever comes first). Codes: I inspect and clean, adjust, replace or lubricate as necessary; R replace; T tighten. More frequent servicing may be performed on motorcycles used under severe conditions. I every 12,000 km (7,500 mi) or 12 months. E-33 model only.
Rear suspension (inspect)

Engine

Factory

Factory: Periodic maintenance chart (Suzuki VL1500 service manual, printed p.2-1 to 2-2; interval columns 1,000 km (600 mi) or 1 month; 6,000 km (4,000 mi) or 6 months; 12,000 (7,500) or 12; 18,000 (11,000) or 18; 24,000 km (15,000 mi) or 24 months, whichever comes first). Codes: I inspect and clean, adjust, replace or lubricate as necessary; R replace; T tighten. More frequent servicing may be performed on motorcycles used under severe conditions. I every 12,000 km (7,500 mi) or 12 months.
Spark plugs (replace)

Engine

Factory

Factory: Periodic maintenance chart (Suzuki VL1500 service manual, printed p.2-1 to 2-2; interval columns 1,000 km (600 mi) or 1 month; 6,000 km (4,000 mi) or 6 months; 12,000 (7,500) or 12; 18,000 (11,000) or 18; 24,000 km (15,000 mi) or 24 months, whichever comes first). Codes: I inspect and clean, adjust, replace or lubricate as necessary; R replace; T tighten. More frequent servicing may be performed on motorcycles used under severe conditions. R every 12,000 km (7,500 mi) or 12 months.
Carburetor synchronization (inspect)

Fuel and air

Factory

Factory: Periodic maintenance chart (Suzuki VL1500 service manual, printed p.2-1 to 2-2; interval columns 1,000 km (600 mi) or 1 month; 6,000 km (4,000 mi) or 6 months; 12,000 (7,500) or 12; 18,000 (11,000) or 18; 24,000 km (15,000 mi) or 24 months, whichever comes first). Codes: I inspect and clean, adjust, replace or lubricate as necessary; R replace; T tighten. More frequent servicing may be performed on motorcycles used under severe conditions. I every 12,000 km (7,500 mi) or 12 months. Also at 1,000 km on the E-33 model only.
Fuel hose (inspect)

Fuel and air

Factory

Factory: Periodic maintenance chart (Suzuki VL1500 service manual, printed p.2-1 to 2-2; interval columns 1,000 km (600 mi) or 1 month; 6,000 km (4,000 mi) or 6 months; 12,000 (7,500) or 12; 18,000 (11,000) or 18; 24,000 km (15,000 mi) or 24 months, whichever comes first). Codes: I inspect and clean, adjust, replace or lubricate as necessary; R replace; T tighten. More frequent servicing may be performed on motorcycles used under severe conditions. I marked at 18,000 and 24,000 km on the scan (the 12,000 km cell sits under the site watermark).
Fuel strainer (inspect)

Fuel and air

Factory

Factory: Periodic maintenance chart (Suzuki VL1500 service manual, printed p.2-1 to 2-2; interval columns 1,000 km (600 mi) or 1 month; 6,000 km (4,000 mi) or 6 months; 12,000 (7,500) or 12; 18,000 (11,000) or 18; 24,000 km (15,000 mi) or 24 months, whichever comes first). Codes: I inspect and clean, adjust, replace or lubricate as necessary; R replace; T tighten. More frequent servicing may be performed on motorcycles used under severe conditions. I every 12,000 km (7,500 mi) or 12 months.
Front forks (inspect)

Front end

Factory

Factory: Periodic maintenance chart (Suzuki VL1500 service manual, printed p.2-1 to 2-2; interval columns 1,000 km (600 mi) or 1 month; 6,000 km (4,000 mi) or 6 months; 12,000 (7,500) or 12; 18,000 (11,000) or 18; 24,000 km (15,000 mi) or 24 months, whichever comes first). Codes: I inspect and clean, adjust, replace or lubricate as necessary; R replace; T tighten. More frequent servicing may be performed on motorcycles used under severe conditions. I every 12,000 km (7,500 mi) or 12 months.
Steering (inspect)

Front end

Factory

Factory: Periodic maintenance chart (Suzuki VL1500 service manual, printed p.2-1 to 2-2; interval columns 1,000 km (600 mi) or 1 month; 6,000 km (4,000 mi) or 6 months; 12,000 (7,500) or 12; 18,000 (11,000) or 18; 24,000 km (15,000 mi) or 24 months, whichever comes first). Codes: I inspect and clean, adjust, replace or lubricate as necessary; R replace; T tighten. More frequent servicing may be performed on motorcycles used under severe conditions. I at 1,000 km (600 mi) or 1 month, then every 12,000 km (7,500 mi) or 12 months.
Evaporative emission control system (inspect)

Controls and cables

Factory

Factory: Periodic maintenance chart (Suzuki VL1500 service manual, printed p.2-1 to 2-2; interval columns 1,000 km (600 mi) or 1 month; 6,000 km (4,000 mi) or 6 months; 12,000 (7,500) or 12; 18,000 (11,000) or 18; 24,000 km (15,000 mi) or 24 months, whichever comes first). Codes: I inspect and clean, adjust, replace or lubricate as necessary; R replace; T tighten. More frequent servicing may be performed on motorcycles used under severe conditions. I every 12,000 km (7,500 mi) or 12 months. E-33 model only; replace vapor hose every 4 years.

Every 13,000 km or 2 years

1 item

Check and adjust valve clearances

Engine

Guideline

Every 16,000 km or 2 years

1 item

Compression test (or leak-down)

Engine

Guideline

Every 18,000 km or 18 months

2 items

Engine oil filter (replace)

Engine

Factory

Factory: Periodic maintenance chart (Suzuki VL1500 service manual, printed p.2-1 to 2-2; interval columns 1,000 km (600 mi) or 1 month; 6,000 km (4,000 mi) or 6 months; 12,000 (7,500) or 12; 18,000 (11,000) or 18; 24,000 km (15,000 mi) or 24 months, whichever comes first). Codes: I inspect and clean, adjust, replace or lubricate as necessary; R replace; T tighten. More frequent servicing may be performed on motorcycles used under severe conditions. R at 1,000 km (600 mi) or 1 month and at 18,000 km (11,000 mi) or 18 months.
Air cleaner (replace)

Fuel and air

Factory

Factory: Periodic maintenance chart (Suzuki VL1500 service manual, printed p.2-1 to 2-2; interval columns 1,000 km (600 mi) or 1 month; 6,000 km (4,000 mi) or 6 months; 12,000 (7,500) or 12; 18,000 (11,000) or 18; 24,000 km (15,000 mi) or 24 months, whichever comes first). Codes: I inspect and clean, adjust, replace or lubricate as necessary; R replace; T tighten. More frequent servicing may be performed on motorcycles used under severe conditions. R at 18,000 km (11,000 mi) or 18 months.

Every 19,500 km or 2 years

4 items

Replace air filter element

Fuel and air

Guideline
Change final drive (rear drive) oil

Final drive

Guideline
Clean and grease rear suspension linkage

Rear suspension and frame

Guideline
Grease swingarm pivot

Rear suspension and frame

Guideline

Every 24,000 km or 3 years

1 item

Change fork oil

Front end

Guideline

Some early telescopic forks are grease filled or use very small oil quantities. Check your manual.

Every 25,500 km or 4 years

1 item

Replace spark plugs

Engine

Guideline

Every 32,000 km or 4 years

3 items

Lubricate drive shaft splines / check U-joint

Final drive

Guideline
Repack / replace steering head bearings

Front end

Guideline

Many old machines use loose balls in cups and cones. Taper roller conversions are common.
Repack / replace wheel bearings

Wheels and tires

Guideline

Cup-and-cone and taper roller hubs need periodic repacking and adjustment.

Every 40,000 km or 6 years

1 item

Replace swingarm bushes / bearings

Rear suspension and frame

Guideline

Every 48,500 km or 6 years

1 item

Rebuild forks: seals, bushes, springs

Front end

Guideline

Every 6 months

1 item

Clean battery terminals, check charge and strap

Ignition and electrics

Guideline

Every 2 years

5 items

Inspect wiring, bullet connectors and ground points

Ignition and electrics

Guideline
Clutch fluid (replace)

Primary and gearbox

Factory

Factory: Periodic maintenance chart (Suzuki VL1500 service manual, printed p.2-1 to 2-2; interval columns 1,000 km (600 mi) or 1 month; 6,000 km (4,000 mi) or 6 months; 12,000 (7,500) or 12; 18,000 (11,000) or 18; 24,000 km (15,000 mi) or 24 months, whichever comes first). Codes: I inspect and clean, adjust, replace or lubricate as necessary; R replace; T tighten. More frequent servicing may be performed on motorcycles used under severe conditions. Replace every 2 years.
Inspect frame, welds and lugs for cracks

Rear suspension and frame

Guideline
Brake fluid (replace)

Brakes

Factory

Factory: Periodic maintenance chart (Suzuki VL1500 service manual, printed p.2-1 to 2-2; interval columns 1,000 km (600 mi) or 1 month; 6,000 km (4,000 mi) or 6 months; 12,000 (7,500) or 12; 18,000 (11,000) or 18; 24,000 km (15,000 mi) or 24 months, whichever comes first). Codes: I inspect and clean, adjust, replace or lubricate as necessary; R replace; T tighten. More frequent servicing may be performed on motorcycles used under severe conditions. Replace every 2 years.
Replace brake fluid

Brakes

Guideline

Every 4 years

6 items

Fuel hose (replace)

Fuel and air

Factory

Factory: Periodic maintenance chart (Suzuki VL1500 service manual, printed p.2-1 to 2-2; interval columns 1,000 km (600 mi) or 1 month; 6,000 km (4,000 mi) or 6 months; 12,000 (7,500) or 12; 18,000 (11,000) or 18; 24,000 km (15,000 mi) or 24 months, whichever comes first). Codes: I inspect and clean, adjust, replace or lubricate as necessary; R replace; T tighten. More frequent servicing may be performed on motorcycles used under severe conditions. Replace every 4 years.
Replace fuel lines

Fuel and air

Guideline

Old rubber and modern ethanol fuel do not mix well.
Clutch hose (replace)

Primary and gearbox

Factory

Factory: Periodic maintenance chart (Suzuki VL1500 service manual, printed p.2-1 to 2-2; interval columns 1,000 km (600 mi) or 1 month; 6,000 km (4,000 mi) or 6 months; 12,000 (7,500) or 12; 18,000 (11,000) or 18; 24,000 km (15,000 mi) or 24 months, whichever comes first). Codes: I inspect and clean, adjust, replace or lubricate as necessary; R replace; T tighten. More frequent servicing may be performed on motorcycles used under severe conditions. Replace every 4 years.
Brake hose (replace)

Brakes

Factory

Factory: Periodic maintenance chart (Suzuki VL1500 service manual, printed p.2-1 to 2-2; interval columns 1,000 km (600 mi) or 1 month; 6,000 km (4,000 mi) or 6 months; 12,000 (7,500) or 12; 18,000 (11,000) or 18; 24,000 km (15,000 mi) or 24 months, whichever comes first). Codes: I inspect and clean, adjust, replace or lubricate as necessary; R replace; T tighten. More frequent servicing may be performed on motorcycles used under severe conditions. Replace every 4 years.
Inspect brake hoses; replace old rubber

Brakes

Guideline
Rebuild calipers and master cylinders (seals)

Brakes

Guideline

Every 6 years

1 item

Replace tires on age (regardless of tread)

Wheels and tires

Guideline

Guideline lines: Intervals here are general guidelines for the machine's era and layout, compiled for this app. They are not factory manual figures. Check your workshop manual, and edit any interval in the bike's Schedule tab.