MotoService Log
No photo of this model in the library yet.
TVS · Overhead-cam four-stroke single, wet sump, gearbox shares engine oil, chain drive

Radeon (110 cc)

Library entry covers 2020-2024

33 factory 51 guideline

Published source

TVS Radeon Owner's Manual (Revision 9, 30 Jan 2024), Periodic maintenance schedule pp.38-39 (official TVS PDF)

Factory source. Covers TVS Radeon owner's manual, Revision 9, as on 30 Jan 2024 (printed on manual p.13); earlier revisions may differ.

84 items for a 2023 model, grouped by interval the way a factory chart is laid out.

How this bike is built (what the schedule is based on)
Engine cycle
Four-stroke
Engine lubrication
Wet sump (oil in crankcase)
Oil filtration
Replaceable cartridge or spin-on filter
Valve gear
Overhead cam, screw/locknut adjusters
Ignition
Electronic (CDI / transistor / ECU)
Charging
Alternator / stator with rectifier
Battery
Wet cell (flooded lead-acid, needs topping up)
Fuel system
Single carburetor
Cooling
Air / oil cooled
Primary drive
Gear or chain inside engine, shares engine oil
Gearbox oil
Shares engine oil
Clutch control
Hand lever, cable
Final drive
Chain
Front suspension
Telescopic fork
Rear suspension
Swingarm, twin shocks
Front brake
Disc, hydraulic
Rear brake
Drum (or band / belt rim)
Wheels
Spoked, tubed
Sidecar
No sidecar
Maintenance schedule

2023 TVS Radeon (110 cc)

On the road: every 300 km

1 item
  • Check engine oil level
    Pre-ride / on the road
    Guideline

    Each fuel stop on old machines. Dry sump: check the tank hot, engine idling or just stopped, per your manual.

On the road: every 500 km

3 items
  • Check lights, horn, brake light switches
    Pre-ride / on the road
    Guideline
  • Check tire pressures
    Pre-ride / on the road
    Guideline
  • Lubricate drive chain
    Pre-ride / on the road
    Guideline

    Lube warm, ideally at the end of the riding day so it soaks in overnight. Sooner after rain.

On the road: every 1,000 km

1 item
  • Check chain slack and rear wheel alignment
    Pre-ride / on the road
    Guideline

Every 1,600 km or 6 months

2 items
  • Adjust rear drum brake and rod / cable linkage
    Brakes
    Guideline
  • Inspect tire tread, sidewalls and date codes
    Wheels and tires
    Guideline

Every 3,000 km or 3 months

18 items
  • All bulbs, horn and switches (inspect)
    Engine
    Factory

    Factory: Periodic maintenance schedule (owner manual printed pp.38-39): at every free service, then every 3000 km / 3 months. Columns as printed (months or km, whichever occurs earlier): free services 1st 500-750 km / 1 month, 2nd 2500-3000 km / 3 months, 3rd 5000-6000 km / 6 months, 4th 8500-9000 km / 9 months, 5th 11500-12000 km / 12 months; after free service every 3000 km / 3 months and every 6000 km / 6 months. Key: R replace, I inspect, T top up, C clean, A adjust, L lubricate, TI tighten, S set.

  • All fasteners (inspect and tighten)
    Engine
    Factory

    Factory: Periodic maintenance schedule (owner manual printed pp.38-39): at every free service, then every 3000 km / 3 months. Columns as printed (months or km, whichever occurs earlier): free services 1st 500-750 km / 1 month, 2nd 2500-3000 km / 3 months, 3rd 5000-6000 km / 6 months, 4th 8500-9000 km / 9 months, 5th 11500-12000 km / 12 months; after free service every 3000 km / 3 months and every 6000 km / 6 months. Key: R replace, I inspect, T top up, C clean, A adjust, L lubricate, TI tighten, S set.

  • Front and rear suspension (inspect)
    Engine
    Factory

    Factory: Periodic maintenance schedule (owner manual printed pp.38-39): at every free service, then every 3000 km / 3 months. Columns as printed (months or km, whichever occurs earlier): free services 1st 500-750 km / 1 month, 2nd 2500-3000 km / 3 months, 3rd 5000-6000 km / 6 months, 4th 8500-9000 km / 9 months, 5th 11500-12000 km / 12 months; after free service every 3000 km / 3 months and every 6000 km / 6 months. Key: R replace, I inspect, T top up, C clean, A adjust, L lubricate, TI tighten, S set.

  • Head lamp beam (inspect and adjust)
    Engine
    Factory

    Factory: Periodic maintenance schedule (owner manual printed pp.38-39): at every free service, then every 3000 km / 3 months. Columns as printed (months or km, whichever occurs earlier): free services 1st 500-750 km / 1 month, 2nd 2500-3000 km / 3 months, 3rd 5000-6000 km / 6 months, 4th 8500-9000 km / 9 months, 5th 11500-12000 km / 12 months; after free service every 3000 km / 3 months and every 6000 km / 6 months. Key: R replace, I inspect, T top up, C clean, A adjust, L lubricate, TI tighten, S set.

  • Kick starter pedal pivot (lubricate with TRU4 oil)
    Engine
    Factory

    Factory: Periodic maintenance schedule (owner manual printed pp.38-39): at every free service, then every 3000 km / 3 months. Columns as printed (months or km, whichever occurs earlier): free services 1st 500-750 km / 1 month, 2nd 2500-3000 km / 3 months, 3rd 5000-6000 km / 6 months, 4th 8500-9000 km / 9 months, 5th 11500-12000 km / 12 months; after free service every 3000 km / 3 months and every 6000 km / 6 months. Key: R replace, I inspect, T top up, C clean, A adjust, L lubricate, TI tighten, S set.

  • Malfunction indicator lamp (inspect; check errors with diagnostic tool if lit)
    Engine
    Factory

    Factory: Periodic maintenance schedule (owner manual printed pp.38-39): at every free service, then every 3000 km / 3 months. Columns as printed (months or km, whichever occurs earlier): free services 1st 500-750 km / 1 month, 2nd 2500-3000 km / 3 months, 3rd 5000-6000 km / 6 months, 4th 8500-9000 km / 9 months, 5th 11500-12000 km / 12 months; after free service every 3000 km / 3 months and every 6000 km / 6 months. Key: R replace, I inspect, T top up, C clean, A adjust, L lubricate, TI tighten, S set.

  • Battery voltage (inspect; recharge if necessary)
    Ignition and electrics
    Factory

    Factory: Periodic maintenance schedule (owner manual printed pp.38-39): at every free service, then every 3000 km / 3 months. Columns as printed (months or km, whichever occurs earlier): free services 1st 500-750 km / 1 month, 2nd 2500-3000 km / 3 months, 3rd 5000-6000 km / 6 months, 4th 8500-9000 km / 9 months, 5th 11500-12000 km / 12 months; after free service every 3000 km / 3 months and every 6000 km / 6 months. Key: R replace, I inspect, T top up, C clean, A adjust, L lubricate, TI tighten, S set.

  • Clutch and throttle play (inspect, adjust, lubricate)
    Primary and gearbox
    Factory

    Factory: Periodic maintenance schedule (owner manual printed pp.38-39): at every free service, then every 3000 km / 3 months. Columns as printed (months or km, whichever occurs earlier): free services 1st 500-750 km / 1 month, 2nd 2500-3000 km / 3 months, 3rd 5000-6000 km / 6 months, 4th 8500-9000 km / 9 months, 5th 11500-12000 km / 12 months; after free service every 3000 km / 3 months and every 6000 km / 6 months. Key: R replace, I inspect, T top up, C clean, A adjust, L lubricate, TI tighten, S set.

  • Drive chain (clean, lubricate, adjust)
    Final drive
    Factory

    Factory: Periodic maintenance schedule (owner manual printed pp.38-39): at every free service, then every 3000 km / 3 months. Columns as printed (months or km, whichever occurs earlier): free services 1st 500-750 km / 1 month, 2nd 2500-3000 km / 3 months, 3rd 5000-6000 km / 6 months, 4th 8500-9000 km / 9 months, 5th 11500-12000 km / 12 months; after free service every 3000 km / 3 months and every 6000 km / 6 months. Key: R replace, I inspect, T top up, C clean, A adjust, L lubricate, TI tighten, S set.

  • Steering smooth operation / play (inspect and adjust)
    Front end
    Factory

    Factory: Periodic maintenance schedule (owner manual printed pp.38-39): at every free service, then every 3000 km / 3 months; clean and lubricate (fresh Bechem grease) at the 5th service. Columns as printed (months or km, whichever occurs earlier): free services 1st 500-750 km / 1 month, 2nd 2500-3000 km / 3 months, 3rd 5000-6000 km / 6 months, 4th 8500-9000 km / 9 months, 5th 11500-12000 km / 12 months; after free service every 3000 km / 3 months and every 6000 km / 6 months. Key: R replace, I inspect, T top up, C clean, A adjust, L lubricate, TI tighten, S set.

  • Center / side stand pivot (lubricate with TRU4 oil)
    Rear suspension and frame
    Factory

    Factory: Periodic maintenance schedule (owner manual printed pp.38-39): at every free service, then every 3000 km / 3 months. Columns as printed (months or km, whichever occurs earlier): free services 1st 500-750 km / 1 month, 2nd 2500-3000 km / 3 months, 3rd 5000-6000 km / 6 months, 4th 8500-9000 km / 9 months, 5th 11500-12000 km / 12 months; after free service every 3000 km / 3 months and every 6000 km / 6 months. Key: R replace, I inspect, T top up, C clean, A adjust, L lubricate, TI tighten, S set.

  • Brake effectiveness / play (inspect and adjust; lubricate brake pedal shaft every service)
    Brakes
    Factory

    Factory: Periodic maintenance schedule (owner manual printed pp.38-39): at every free service, then every 3000 km / 3 months. Columns as printed (months or km, whichever occurs earlier): free services 1st 500-750 km / 1 month, 2nd 2500-3000 km / 3 months, 3rd 5000-6000 km / 6 months, 4th 8500-9000 km / 9 months, 5th 11500-12000 km / 12 months; after free service every 3000 km / 3 months and every 6000 km / 6 months. Key: R replace, I inspect, T top up, C clean, A adjust, L lubricate, TI tighten, S set.

  • Brake fluid (inspect and top up; disc brake version)
    Brakes
    Factory

    Factory: Periodic maintenance schedule (owner manual printed pp.38-39): at every free service, then every 3000 km / 3 months. Columns as printed (months or km, whichever occurs earlier): free services 1st 500-750 km / 1 month, 2nd 2500-3000 km / 3 months, 3rd 5000-6000 km / 6 months, 4th 8500-9000 km / 9 months, 5th 11500-12000 km / 12 months; after free service every 3000 km / 3 months and every 6000 km / 6 months. Key: R replace, I inspect, T top up, C clean, A adjust, L lubricate, TI tighten, S set.

  • Brake hose (inspect; disc brake version)
    Brakes
    Factory

    Factory: Periodic maintenance schedule (owner manual printed pp.38-39): at every free service, then every 3000 km / 3 months; replace every three years. Columns as printed (months or km, whichever occurs earlier): free services 1st 500-750 km / 1 month, 2nd 2500-3000 km / 3 months, 3rd 5000-6000 km / 6 months, 4th 8500-9000 km / 9 months, 5th 11500-12000 km / 12 months; after free service every 3000 km / 3 months and every 6000 km / 6 months. Key: R replace, I inspect, T top up, C clean, A adjust, L lubricate, TI tighten, S set.

  • Brake pad wear (inspect; disc brake version)
    Brakes
    Factory

    Factory: Periodic maintenance schedule (owner manual printed pp.38-39): at every free service, then every 3000 km / 3 months. Columns as printed (months or km, whichever occurs earlier): free services 1st 500-750 km / 1 month, 2nd 2500-3000 km / 3 months, 3rd 5000-6000 km / 6 months, 4th 8500-9000 km / 9 months, 5th 11500-12000 km / 12 months; after free service every 3000 km / 3 months and every 6000 km / 6 months. Key: R replace, I inspect, T top up, C clean, A adjust, L lubricate, TI tighten, S set.

  • Disc brake SBT cable play (inspect; disc brake version)
    Brakes
    Factory

    Factory: Periodic maintenance schedule (owner manual printed pp.38-39): at every free service, then every 3000 km / 3 months; inspect the SBT inner cable and front brake lever slackness and adjust if required. Columns as printed (months or km, whichever occurs earlier): free services 1st 500-750 km / 1 month, 2nd 2500-3000 km / 3 months, 3rd 5000-6000 km / 6 months, 4th 8500-9000 km / 9 months, 5th 11500-12000 km / 12 months; after free service every 3000 km / 3 months and every 6000 km / 6 months. Key: R replace, I inspect, T top up, C clean, A adjust, L lubricate, TI tighten, S set.

  • Tire pressure, cold (inspect and set)
    Wheels and tires
    Factory

    Factory: Periodic maintenance schedule (owner manual printed pp.38-39): at every free service, then every 3000 km / 3 months. Columns as printed (months or km, whichever occurs earlier): free services 1st 500-750 km / 1 month, 2nd 2500-3000 km / 3 months, 3rd 5000-6000 km / 6 months, 4th 8500-9000 km / 9 months, 5th 11500-12000 km / 12 months; after free service every 3000 km / 3 months and every 6000 km / 6 months. Key: R replace, I inspect, T top up, C clean, A adjust, L lubricate, TI tighten, S set.

  • Wheel freeness (inspect)
    Wheels and tires
    Factory

    Factory: Periodic maintenance schedule (owner manual printed pp.38-39): at every free service, then every 3000 km / 3 months. Columns as printed (months or km, whichever occurs earlier): free services 1st 500-750 km / 1 month, 2nd 2500-3000 km / 3 months, 3rd 5000-6000 km / 6 months, 4th 8500-9000 km / 9 months, 5th 11500-12000 km / 12 months; after free service every 3000 km / 3 months and every 6000 km / 6 months. Key: R replace, I inspect, T top up, C clean, A adjust, L lubricate, TI tighten, S set.

Every 5,000 km or 12 months

11 items
  • Check throttle cable(s) free play and return
    Fuel and air
    Guideline
  • Clean fuel tap filter / sediment bowl
    Fuel and air
    Guideline
  • Clean drive chain thoroughly (remove and soak, re-lube)
    Final drive
    Guideline

    Non O-ring chains on old machines: remove, clean, soak in hot chain grease or lube, refit with the master link clip closed end leading.

  • Inspect chain and sprockets for wear (measure stretch)
    Final drive
    Guideline
  • Check steering head bearing adjustment
    Front end
    Guideline
  • Inspect fork seals, stanchions and fork boots
    Front end
    Guideline
  • Check footrests, pegs, rear brake and gear lever pivots
    Rear suspension and frame
    Guideline
  • Grease and check center / side stand and springs
    Rear suspension and frame
    Guideline
  • Check brake pads and discs
    Brakes
    Guideline
  • Check spoke tension and wheel true
    Wheels and tires
    Guideline
  • Check wheel bearings for play
    Wheels and tires
    Guideline

Every 6,000 km or 6 months

6 items
  • Centrifugal filter (clean)
    Engine
    Factory

    Factory: Periodic maintenance schedule (owner manual printed pp.38-39): at the 3rd and 5th services, then every 6000 km / 6 months. Columns as printed (months or km, whichever occurs earlier): free services 1st 500-750 km / 1 month, 2nd 2500-3000 km / 3 months, 3rd 5000-6000 km / 6 months, 4th 8500-9000 km / 9 months, 5th 11500-12000 km / 12 months; after free service every 3000 km / 3 months and every 6000 km / 6 months. Key: R replace, I inspect, T top up, C clean, A adjust, L lubricate, TI tighten, S set.

  • Oil filter strainer (clean)
    Engine
    Factory

    Factory: Periodic maintenance schedule (owner manual printed pp.38-39): at the 1st, 3rd and 5th services, then every 6000 km / 6 months. Columns as printed (months or km, whichever occurs earlier): free services 1st 500-750 km / 1 month, 2nd 2500-3000 km / 3 months, 3rd 5000-6000 km / 6 months, 4th 8500-9000 km / 9 months, 5th 11500-12000 km / 12 months; after free service every 3000 km / 3 months and every 6000 km / 6 months. Key: R replace, I inspect, T top up, C clean, A adjust, L lubricate, TI tighten, S set.

  • Tappet clearance (inspect and adjust)
    Engine
    Factory

    Factory: Periodic maintenance schedule (owner manual printed pp.38-39): inspect at the 1st service; inspect and adjust at the 3rd and 5th services, then every 6000 km / 6 months. Columns as printed (months or km, whichever occurs earlier): free services 1st 500-750 km / 1 month, 2nd 2500-3000 km / 3 months, 3rd 5000-6000 km / 6 months, 4th 8500-9000 km / 9 months, 5th 11500-12000 km / 12 months; after free service every 3000 km / 3 months and every 6000 km / 6 months. Key: R replace, I inspect, T top up, C clean, A adjust, L lubricate, TI tighten, S set.

  • Throttle grip (lubricate with grease)
    Engine
    Factory

    Factory: Periodic maintenance schedule (owner manual printed pp.38-39): at the 3rd and 5th services, then every 6000 km / 6 months. Columns as printed (months or km, whichever occurs earlier): free services 1st 500-750 km / 1 month, 2nd 2500-3000 km / 3 months, 3rd 5000-6000 km / 6 months, 4th 8500-9000 km / 9 months, 5th 11500-12000 km / 12 months; after free service every 3000 km / 3 months and every 6000 km / 6 months. Key: R replace, I inspect, T top up, C clean, A adjust, L lubricate, TI tighten, S set.

  • Engine cum transmission oil (replace)
    Primary and gearbox
    Factory

    Factory: Periodic maintenance schedule (owner manual printed pp.38-39): replace at the 1st, 3rd and 5th services, then every 6000 km / 6 months; inspect and top up at the 2nd and 4th services and every 3000 km / 3 months. Columns as printed (months or km, whichever occurs earlier): free services 1st 500-750 km / 1 month, 2nd 2500-3000 km / 3 months, 3rd 5000-6000 km / 6 months, 4th 8500-9000 km / 9 months, 5th 11500-12000 km / 12 months; after free service every 3000 km / 3 months and every 6000 km / 6 months. Key: R replace, I inspect, T top up, C clean, A adjust, L lubricate, TI tighten, S set.

  • Brake cams / SBT system parts (clean and lubricate with grease)
    Brakes
    Factory

    Factory: Periodic maintenance schedule (owner manual printed pp.38-39): at the 3rd and 5th services, then every 6000 km / 6 months. Columns as printed (months or km, whichever occurs earlier): free services 1st 500-750 km / 1 month, 2nd 2500-3000 km / 3 months, 3rd 5000-6000 km / 6 months, 4th 8500-9000 km / 9 months, 5th 11500-12000 km / 12 months; after free service every 3000 km / 3 months and every 6000 km / 6 months. Key: R replace, I inspect, T top up, C clean, A adjust, L lubricate, TI tighten, S set.

Every 6,500 km or 12 months

3 items
  • Inspect, clean and gap spark plugs
    Engine
    Guideline
  • Adjust clutch free play, lubricate cable and lever pivot
    Primary and gearbox
    Guideline
  • Lubricate brake cam spindles, check linings and drums
    Brakes
    Guideline

Every 8,000 km or 12 months

2 items
  • Change engine oil
    Engine
    Guideline

    Pre-1970 machines: many owners run non-detergent or classic-spec oil with no filter, so short intervals matter. Dry sump: drain the tank and the crankcase/sump, flush the tank and clean the feed and return screens.

  • Replace oil filter
    Engine
    Guideline

Every 9,500 km or 12 months

7 items
  • Clean / inspect air filter
    Fuel and air
    Guideline

    Mesh or oiled foam: clean and re-oil. Paper: blow out or replace. Some very early machines have no filter at all.

  • Clean carburetor float bowl(s), check float level and jets
    Fuel and air
    Guideline

    Ethanol fuel varnishes old carbs quickly in storage.

  • Check charging voltage and regulator / cut-out
    Ignition and electrics
    Guideline
  • Check swingarm bushes for play
    Rear suspension and frame
    Guideline
  • Inspect rear shocks for leaks and damping
    Rear suspension and frame
    Guideline
  • Lubricate control cables and lever pivots
    Controls and cables
    Guideline
  • Lubricate speedometer / tachometer cables, check drive
    Controls and cables
    Guideline

    A dry speedo cable whips the needle and eventually kills the instrument.

Every 12,000 km

2 items
  • Spark plug (replace)
    Engine
    Factory

    Factory: Periodic maintenance schedule (owner manual printed pp.38-39): inspect at the 1st service; replace at the 5th service; replace every 12000 km. Columns as printed (months or km, whichever occurs earlier): free services 1st 500-750 km / 1 month, 2nd 2500-3000 km / 3 months, 3rd 5000-6000 km / 6 months, 4th 8500-9000 km / 9 months, 5th 11500-12000 km / 12 months; after free service every 3000 km / 3 months and every 6000 km / 6 months. Key: R replace, I inspect, T top up, C clean, A adjust, L lubricate, TI tighten, S set.

  • Air cleaner element (replace)
    Fuel and air
    Factory

    Factory: Periodic maintenance schedule (owner manual printed pp.38-39): inspect at the 1st service; replace at the 5th service; replace every 12000 km. Columns as printed (months or km, whichever occurs earlier): free services 1st 500-750 km / 1 month, 2nd 2500-3000 km / 3 months, 3rd 5000-6000 km / 6 months, 4th 8500-9000 km / 9 months, 5th 11500-12000 km / 12 months; after free service every 3000 km / 3 months and every 6000 km / 6 months. Key: R replace, I inspect, T top up, C clean, A adjust, L lubricate, TI tighten, S set.

Every 13,000 km or 2 years

1 item
  • Check and adjust valve clearances
    Engine
    Guideline

Every 16,000 km or 2 years

1 item
  • Compression test (or leak-down)
    Engine
    Guideline

Every 18,000 km

1 item
  • Front fork oil (replace)
    Front end
    Factory

    Factory: Periodic maintenance schedule (owner manual printed pp.38-39): every 18000 km. Columns as printed (months or km, whichever occurs earlier): free services 1st 500-750 km / 1 month, 2nd 2500-3000 km / 3 months, 3rd 5000-6000 km / 6 months, 4th 8500-9000 km / 9 months, 5th 11500-12000 km / 12 months; after free service every 3000 km / 3 months and every 6000 km / 6 months. Key: R replace, I inspect, T top up, C clean, A adjust, L lubricate, TI tighten, S set.

Every 19,500 km or 2 years

2 items
  • Replace air filter element
    Fuel and air
    Guideline
  • Grease swingarm pivot
    Rear suspension and frame
    Guideline

Every 21,000 km or 2 years

1 item
  • Brake fluid (replace; disc brake version)
    Brakes
    Factory

    Factory: Periodic maintenance schedule (owner manual printed pp.38-39): every 21000 km or 2 years, whichever is earlier. Columns as printed (months or km, whichever occurs earlier): free services 1st 500-750 km / 1 month, 2nd 2500-3000 km / 3 months, 3rd 5000-6000 km / 6 months, 4th 8500-9000 km / 9 months, 5th 11500-12000 km / 12 months; after free service every 3000 km / 3 months and every 6000 km / 6 months. Key: R replace, I inspect, T top up, C clean, A adjust, L lubricate, TI tighten, S set.

Every 21,000 km

1 item
  • Master cylinder cups (replace; disc brake version)
    Brakes
    Factory

    Factory: Periodic maintenance schedule (owner manual printed pp.38-39): every 21000 km. Columns as printed (months or km, whichever occurs earlier): free services 1st 500-750 km / 1 month, 2nd 2500-3000 km / 3 months, 3rd 5000-6000 km / 6 months, 4th 8500-9000 km / 9 months, 5th 11500-12000 km / 12 months; after free service every 3000 km / 3 months and every 6000 km / 6 months. Key: R replace, I inspect, T top up, C clean, A adjust, L lubricate, TI tighten, S set.

Every 24,000 km or 3 years

1 item
  • Change fork oil
    Front end
    Guideline

    Some early telescopic forks are grease filled or use very small oil quantities. Check your manual.

Every 24,000 km

2 items
  • Fuel filter (replace)
    Fuel and air
    Factory

    Factory: Periodic maintenance schedule (owner manual printed pp.38-39): every 24000 km. Columns as printed (months or km, whichever occurs earlier): free services 1st 500-750 km / 1 month, 2nd 2500-3000 km / 3 months, 3rd 5000-6000 km / 6 months, 4th 8500-9000 km / 9 months, 5th 11500-12000 km / 12 months; after free service every 3000 km / 3 months and every 6000 km / 6 months. Key: R replace, I inspect, T top up, C clean, A adjust, L lubricate, TI tighten, S set.

  • Replace brake linings / skim drums (wear based)
    Brakes
    Guideline

Every 25,500 km or 4 years

1 item
  • Replace spark plugs
    Engine
    Guideline

Every 29,000 km

1 item
  • Replace chain and sprockets (wear based)
    Final drive
    Guideline

Every 32,000 km or 4 years

2 items
  • Repack / replace steering head bearings
    Front end
    Guideline

    Many old machines use loose balls in cups and cones. Taper roller conversions are common.

  • Repack / replace wheel bearings
    Wheels and tires
    Guideline

    Cup-and-cone and taper roller hubs need periodic repacking and adjustment.

Every 40,000 km or 6 years

1 item
  • Replace swingarm bushes / bearings
    Rear suspension and frame
    Guideline

Every 48,500 km or 6 years

1 item
  • Rebuild forks: seals, bushes, springs
    Front end
    Guideline

Every 6 months

1 item
  • Clean battery terminals, check charge and strap
    Ignition and electrics
    Guideline

Every 2 years

3 items
  • Inspect wiring, bullet connectors and ground points
    Ignition and electrics
    Guideline
  • Inspect frame, welds and lugs for cracks
    Rear suspension and frame
    Guideline
  • Replace brake fluid
    Brakes
    Guideline

Every 3 years

1 item
  • Brake hose (replace; disc brake version)
    Brakes
    Factory

    Factory: Periodic maintenance schedule (owner manual printed pp.38-39): every three years. Columns as printed (months or km, whichever occurs earlier): free services 1st 500-750 km / 1 month, 2nd 2500-3000 km / 3 months, 3rd 5000-6000 km / 6 months, 4th 8500-9000 km / 9 months, 5th 11500-12000 km / 12 months; after free service every 3000 km / 3 months and every 6000 km / 6 months. Key: R replace, I inspect, T top up, C clean, A adjust, L lubricate, TI tighten, S set.

Every 4 years

5 items
  • Fuel hose (inspect)
    Fuel and air
    Factory

    Factory: Periodic maintenance schedule (owner manual printed pp.38-39): inspect every service after four years; replace if required. Columns as printed (months or km, whichever occurs earlier): free services 1st 500-750 km / 1 month, 2nd 2500-3000 km / 3 months, 3rd 5000-6000 km / 6 months, 4th 8500-9000 km / 9 months, 5th 11500-12000 km / 12 months; after free service every 3000 km / 3 months and every 6000 km / 6 months. Key: R replace, I inspect, T top up, C clean, A adjust, L lubricate, TI tighten, S set.

  • Replace fuel lines
    Fuel and air
    Guideline

    Old rubber and modern ethanol fuel do not mix well.

  • Inspect brake hoses; replace old rubber
    Brakes
    Guideline
  • Rebuild calipers and master cylinders (seals)
    Brakes
    Guideline
  • Evaporative emission control system and hoses (inspect)
    Controls and cables
    Factory

    Factory: Periodic maintenance schedule (owner manual printed pp.38-39): inspect every service after four years; replace if required. Columns as printed (months or km, whichever occurs earlier): free services 1st 500-750 km / 1 month, 2nd 2500-3000 km / 3 months, 3rd 5000-6000 km / 6 months, 4th 8500-9000 km / 9 months, 5th 11500-12000 km / 12 months; after free service every 3000 km / 3 months and every 6000 km / 6 months. Key: R replace, I inspect, T top up, C clean, A adjust, L lubricate, TI tighten, S set.

Every 6 years

2 items
  • Replace inner tubes and rim tape with tires
    Wheels and tires
    Guideline
  • Replace tires on age (regardless of tread)
    Wheels and tires
    Guideline

Guideline lines: Intervals here are general guidelines for the machine's era and layout, compiled for this app. They are not factory manual figures. Check your workshop manual, and edit any interval in the bike's Schedule tab.

Keep up with this schedule on your phone

Add the bike in the app and this chart loads itself, ready to log against and edit.

Coming soon to Google Play

Other 2023 TVS models

All 2023 TVS