No photo of this model in the library yet.

Have this bike? Send a photo or the manual's service chart

Kymco · Overhead-cam four-stroke single, wet sump, separate gearbox oil, CVT belt drive

Agility 50

Library entry covers 2006-2025

13 factory 39 guideline

Published source

Kymco Agility 50 (four-stroke) Manual de usuario (Spanish, Kymco Spain), Tabla de mantenimiento p.055 (factory PDF, copy on archive.org)

Factory owner's handbook. Covers Agility 50 four-stroke, Spanish-market manual.

Open the source

52 items for a 2011 model, grouped by interval the way a factory chart is laid out.

How this bike is built (what the schedule is based on)

Engine cycle: Four-stroke
Engine lubrication: Wet sump (oil in crankcase)
Oil filtration: Replaceable cartridge or spin-on filter
Valve gear: Overhead cam, screw/locknut adjusters
Ignition: Electronic (CDI / transistor / ECU)
Charging: Alternator / stator with rectifier
Battery: Wet cell (flooded lead-acid, needs topping up)
Fuel system: Fuel injection
Cooling: Air / oil cooled
Primary drive: Gear or chain inside engine, shares engine oil
Gearbox oil: Separate gearbox oil
Clutch control: Automatic or semi-automatic
Final drive: Belt CVT, scooter automatic
Front suspension: Telescopic fork
Rear suspension: Swingarm, single shock / cantilever
Front brake: Disc, hydraulic
Rear brake: Drum (or band / belt rim)
Wheels: Cast / alloy, tubeless
Sidecar: No sidecar

Maintenance schedule

2011 Kymco Agility 50

On the road: every 300 km

1 item

Check engine oil level

Pre-ride / on the road

Guideline

Each fuel stop on old machines. Dry sump: check the tank hot, engine idling or just stopped, per your manual.

On the road: every 500 km

1 item

Check lights, horn, brake light switches

Pre-ride / on the road

Guideline

On the road: every 4,000 km

1 item

Check tire pressures

Pre-ride / on the road

Factory

Manual: PRESIÓN DE LOS NEUMÁTICOS. Factory: C at 300, 3k, 7k, 11k km; daily check.

Every 1,000 km

1 item

Clean / inspect air filter

Fuel and air

Factory

Manual: FILTRO DEL AIRE. Factory: Clean every 1,000 km.

Every 1,600 km or 6 months

2 items

Adjust rear drum brake and rod / cable linkage

Brakes

Guideline
Inspect tire tread, sidewalls and date codes

Wheels and tires

Guideline

Every 2,000 km

3 items

Change engine oil

Engine

Factory

Manual: ACEITE MOTOR. Factory: S at 300, 1,000 km then every 2,000 km; check daily. Cols 300/1.000/3.000/5.000/7.000/9.000/11.000/13.000 km.
Inspect, clean and gap spark plugs

Engine

Factory

Manual: BUJÍA. Factory: Clean every 2,000 km.
Replace air filter element

Fuel and air

Factory

Manual: FILTRO DEL AIRE. Factory: Replace every 2,000 km.

Every 4,000 km or 12 months

1 item

Change final drive (rear drive) oil

Final drive

Factory

Manual: ACEITE CAJA REDUCTORA. Factory: S at 300/1k/3k/7k/11k; note 2 says every year or 10,000 km.

Every 4,000 km

5 items

Check and adjust valve clearances

Engine

Factory

Manual: JUEGO DE VÁLVULAS. Factory: A at 300, 3k, 7k, 11k km.
Clean oil strainers / mesh screens

Engine

Factory

Manual: TAMIZ FILTRO ACEITE MOTOR. Factory: L (clean) at 300, 3k, 7k, 11k km.
CARBURADOR

Fuel and air

Factory

Factory: C at 3k, 7k, 11k km.
Inspect drive belt, pulleys and tension

Final drive

Factory

Manual: CORREA VARIADOR. Factory: C at 7k and 13k; note 3: check every 4,000 km after replacement.
Check brake pads and discs

Brakes

Factory

Manual: SISTEMA DE FRENOS. Factory: C at 300, 3k, 7k, 11k km; daily check.

Every 5,000 km or 12 months

7 items

Check throttle cable(s) free play and return

Fuel and air

Guideline
Adjust automatic / semi-automatic clutch

Primary and gearbox

Guideline
Check steering head bearing adjustment

Front end

Guideline
Inspect fork seals, stanchions and fork boots

Front end

Guideline
Check footrests, pegs, rear brake and gear lever pivots

Rear suspension and frame

Guideline
Grease and check center / side stand and springs

Rear suspension and frame

Guideline
Check wheel bearings for play

Wheels and tires

Guideline

Every 5,000 km

1 item

Replace spark plugs

Engine

Factory

Manual: BUJÍA. Factory: Replace every 5,000 km.

Every 6,500 km or 12 months

2 items

Inspect CVT drive belt, rollers / sliders and clutch shoes

Final drive

Guideline

Typical scooter interval. Your owner's manual figure governs; check belt width against the service limit.
Lubricate brake cam spindles, check linings and drums

Brakes

Guideline

Every 8,000 km or 12 months

1 item

Replace oil filter

Engine

Guideline

Every 9,500 km or 12 months

5 items

Check charging voltage and regulator / cut-out

Ignition and electrics

Guideline
Check swingarm bushes for play

Rear suspension and frame

Guideline
Inspect rear shocks for leaks and damping

Rear suspension and frame

Guideline
Lubricate control cables and lever pivots

Controls and cables

Guideline
Lubricate speedometer / tachometer cables, check drive

Controls and cables

Guideline

A dry speedo cable whips the needle and eventually kills the instrument.

Every 16,000 km or 2 years

2 items

Compression test (or leak-down)

Engine

Guideline
Change gearbox oil

Primary and gearbox

Guideline

Every 19,500 km or 2 years

3 items

Synchronize throttle bodies

Fuel and air

Guideline
Clean and grease rear suspension linkage

Rear suspension and frame

Guideline
Grease swingarm pivot

Rear suspension and frame

Guideline

Every 19,500 km or 3 years

1 item

Replace CVT drive belt

Final drive

Guideline

Typical scooter interval, or sooner if the belt is cracked, glazed or below its width limit.

Every 24,000 km or 3 years

1 item

Change fork oil

Front end

Guideline

Some early telescopic forks are grease filled or use very small oil quantities. Check your manual.

Every 24,000 km

1 item

Replace brake linings / skim drums (wear based)

Brakes

Guideline

Every 32,000 km or 4 years

2 items

Repack / replace steering head bearings

Front end

Guideline

Many old machines use loose balls in cups and cones. Taper roller conversions are common.
Repack / replace wheel bearings

Wheels and tires

Guideline

Cup-and-cone and taper roller hubs need periodic repacking and adjustment.

Every 38,500 km or 4 years

1 item

Replace fuel filter

Fuel and air

Guideline

Every 40,000 km or 6 years

1 item

Replace swingarm bushes / bearings

Rear suspension and frame

Guideline

Every 48,500 km or 6 years

1 item

Rebuild forks: seals, bushes, springs

Front end

Guideline

Every 6 months

1 item

Clean battery terminals, check charge and strap

Ignition and electrics

Guideline

Every 2 years

3 items

Inspect wiring, bullet connectors and ground points

Ignition and electrics

Guideline
Inspect frame, welds and lugs for cracks

Rear suspension and frame

Guideline
Replace brake fluid

Brakes

Factory

Manual: Líquido de frenos (nota 4). Factory: Note 4: replace brake fluid every two years.

Every 4 years

3 items

Replace fuel lines

Fuel and air

Guideline

Old rubber and modern ethanol fuel do not mix well.
Inspect brake hoses; replace old rubber

Brakes

Guideline
Rebuild calipers and master cylinders (seals)

Brakes

Guideline

Every 6 years

1 item

Replace tires on age (regardless of tread)

Wheels and tires

Guideline

Guideline lines: Intervals here are general guidelines for the machine's era and layout, compiled for this app. They are not factory manual figures. Check your workshop manual, and edit any interval in the bike's Schedule tab.